2001 HYUNDAI SANTA FE RECALL - #03V030000
RECALL FOR ELECTRICAL SYSTEM : STARTER ASSEMBLY
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 2.7 LITER V-6 ENGINES, IMPROPERLY MANUFACTURED CRANKSHAFT POSITION SENSORS (CPS) WERE INSTALLED. THE CPS CASES WERE IMPROPERLY MANUFACTURED AND DID NOT MEET DIMENSIONAL SPECIFICATIONS. INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE PRINTED CIRCUIT BOARD CAPACITOR.
Information provided by the
National Highway Traffic Safety Administration.
•
Send to a friend
•
Hide Form
Recall Details
| Vehicle |
2001 HYUNDAI SANTA FE |
|
| Manufacturer |
HYUNDAI MOTOR COMPANY |
| Manufactured between |
3/31/2000 - 8/14/2001 |
| Recalled on |
2/5/2003 |
| Influenced by |
HYUNDAI MOTOR COMPANY |
| Owners Notified on |
3/10/2003 |
| # Affected |
25,643 |
| Recalled for |
ELECTRICAL SYSTEM:STARTER ASSEMBLY |
|
|
| Description |
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 2.7 LITER V-6 ENGINES, IMPROPERLY MANUFACTURED CRANKSHAFT POSITION SENSORS (CPS) WERE INSTALLED. THE CPS CASES WERE IMPROPERLY MANUFACTURED AND DID NOT MEET DIMENSIONAL SPECIFICATIONS. INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE PRINTED CIRCUIT BOARD CAPACITOR. |
| Consequences |
A DAMAGED CPS CAPACITOR COULD RESULT IN ENGINE STALLING. |
| Corrective action |
DEALERS WILL REPLACE THE CPS. OWNER NOTIFICATION BEGAN ON MARCH 10, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT HYUNDAI AT 1-800-829-9956. |
| Notes |
HYUNDAI RECALL NO. 049.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236). |
| See also |
2001 HYUNDAI SANTA FE Recall for EQUIPMENT, OTHER, LABELS
2001 HYUNDAI SANTA FE Recall for SUSPENSION, REAR
2001 HYUNDAI SANTA FE Recall for SUSPENSION, FRONT, SPRINGS, COIL SPRINGS
|
| Technical Service Bulletins |
Jun 09, 2021 - 100000 POWER TRAIN
Hyundai approves only the ATF, DCT gear oil and IVT gear oil specified in the vehicle+ó-+-+s owner+ó-+-+s manual. +»-+-+ Use of other ATF may result in improper shift quality or other drivability conditions. +»-+-+ Use of other DCT and IV
Apr 06, 2021 - 030000 BRAKES (PWS)
This bulletin provides best practice recommendations when performing brake service procedures.
Apr 06, 2021 - 060000 ENGINE AND ENGINE COOLING
This bulletin provides the inspection procedure and repair guidelines for certain vehicles listed below.
Apr 06, 2021 - 060000 ENGINE AND ENGINE COOLING
This bulletin provides the service procedure for engine connecting rod bearing clearance testing. Perform the procedure outlined in this bulletin to fulfill the Bearing Clearance Test inspection requirements to determine next required steps
Dec 07, 2020 - 030000 BRAKES (PWS)
This bulletin describes the procedure to inspect and identify fluid which may appear around the brake caliper area.
View all Technical Service Bulletins
|
|
Comments
1/4/2011 - Julia
I have a 2001 Sante fe V6 4wheel drive. I have replaced the brakes for corrosion so many time i have lost count. I have replaced the transmission. My vehicle sqeakes in the back while i drive. When I break sometime I have to pump my breaks to actually stop they begin grinding. Help I spend around a $1000 a year to inspect plus other maintance. I believe i may need a new thermostat now.
5/25/2010 - sherry
i have a 2001 sante fe v6 4wheel drive and i have replaced that alternator 3 times in less then a year ,,something keeps burning them up ,,and when i turn my air on the car sputters ,or when i slow down and go to asselerate the car again it sputters and the engine light comes on ,,i have to pull over shut the suv off then restart to get power back