|
Problem: New Flyer Industries, Ltd. (New Flyer) is recalling certain model year 2015 New Flyer MD30, 2012 C35LFR, 2010-2011 D35LFR, NABI 35LFW, 2011 D40LFR, 2010-2012 D60LFR and NABI 31LFW, 2010 C40LF, DE35LF, D40LF, DE40LFA, DE60LFA, GE35LFR and GE40LF, 2009 DE60LF and GE40LFR, 2010-2013 C40LFR, DE60LFR, NABI 416 and NABI 60BRT, 2010-2015 XD35, XDE40, NABI 40LFW and 42BRT, 2011-2015 XD40 and XN40, 2013-2015 XD60, XDE60 and XN35, 2010-2014 XDE35, 2013 XE40, 2012-2015 XN60, equipped with certain Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2004-2009 TRANSIT BUSES. THESE MODELS HAVE AN INSPECTION PANEL LOCATED ABOVE THE DRIVE SHAFT IN THE PASSENGER COMPARTMENT FLOORING FOR EASY INSPECTION AND REMOVAL OF THE DRIVE SHAFT. THIS PANEL MAY NOT BE OF SUFFICIENT STRENGTH TO PREVENT FOREIGN MATTER FROM ENTERING THE PASSENGER COMPARTMENT IN THE EVENT OF A DRIVE SHAFT FAILURE. Recall Details
Problem: New Flyer is recalling certain model year 2004-2011 transit buses, models: C35LF, C40LFR, D35LFR, D40LF, D40LFR, D60LF, D60LFA, D60LFR, DE35LFA, DE40LF, DE40LFA, DE40LFR, DE60LF, DE60LFA, DE60LFR, and XDE40. The drive shaft access panel may have insufficient strength or be not properly secured to the floor. If the drive shaft fails, debris from the driveshaft failure may enter the passenger compartment through the panel. Recall Details
Problem: New Flyer is recalling certain model year 2004-2011 transit buses, models: C35LF, C40LFR, D35LFR, D40LF, D40LFR, D60LF, D60LFA, D60LFR, DE35LFA, DE40LF, DE40LFA, DE40LFR, DE60LF, DE60LFA, DE60LFR, and XDE40. The drive shaft access panel may have insufficient strength or be not properly secured to the floor. If the drive shaft fails, debris from the driveshaft failure may enter the passenger compartment through the panel. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2004-2009 TRANSIT BUSES. THESE MODELS HAVE AN INSPECTION PANEL LOCATED ABOVE THE DRIVE SHAFT IN THE PASSENGER COMPARTMENT FLOORING FOR EASY INSPECTION AND REMOVAL OF THE DRIVE SHAFT. THIS PANEL MAY NOT BE OF SUFFICIENT STRENGTH TO PREVENT FOREIGN MATTER FROM ENTERING THE PASSENGER COMPARTMENT IN THE EVENT OF A DRIVE SHAFT FAILURE. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2007-2011 LOW FLOOR TRANSIT BUSES PRODUCED FROM MAY 24, 2007, THROUGH MARCH 1, 2011 AND EQUIPPED WITH TEETER LEVER ASSEMBLIES. THERE IS INSUFFICIENT ENGAGEMENT BETWEEN THE TEETER LEVER BASE AND THE CAM PLATE. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2008 C40LFR, D40LF AND DE60LF HEAVY DUTY TRANSIT BUSES, AS WELL AS MODEL YEAR 2009 DE60LFA HEAVY DUTY TRANSIT BUSES. THE PASSENGER ASSIST GRAB STRAP HANDLES HAVE EXPERIENCED MULTIPLE FAILURES IN THE FIELD. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2008-2009 HEAVY DUTY TRANSIT BUSES. THE RADIUS ROD BRACKET WHICH ATTACHES THE FRONT AXLE RADIUS RODS TO THE VEHICLE FRAME MAY BE MISSING TWO OF THE FOUR REQUIRED WELDS. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: NEW FLYER IS RECALLING 319 MY 2008 C40LF, C40LFR, D35LF, D40LF, D41LF, D61LFR, DE41LF, DE61LF, E40LFR, GE40LFR, AND DE41LFR TRANSIT BUSES EQUIPPED WITH PARKER HANNIFIN (VANSCO) CONTROL MODULES. A CERTAIN BATCH OF THE PROGRAMMABLE LOGIC CONTROL MODULES MAY HAVE A MANUFACTURING DEFECT. THIS DEFECT COULD PRODUCE ERRATIC BEHAVIOR OF CERTAIN INPUT/OUTPUT SIGNALS TO AND FROM THE AFFECTED MODULE. THIS ERRATIC BEHAVIOR COULD POTENTIALLY IMPACT CERTAIN FUNCTIONS SUCH AS THE HEADLIGHTS, BRAKE LIGHTS, THROTTLE CONTROL, AND CONTROL OF THE ARTICULATED JOINT. Recall Details
Problem: CERTAIN BUSES HAVE STAINLESS STEEL HYDRAULIC LINES WITH 90? FLANGE FITTINGS WHICH ARE SUBJECT TO FAILURE DUE TO ERRORS IN BOTH THE DESIGN AND MANUFACTURE OF THESE LINES. Recall Details
Problem: NEW FLYER IS RECALLING 1,001 MY 2004-2007 D40LF, MY 2005 D40LFR, AND MY 2007-2008 D60LFR TRANSIT BUSES EQUIPPED WITH CE NIEHOFF C701A OR C703A ALTERNATORS. FAILURE OF THE FORWARD ALTERNATOR BEARING MAY RESULT IN A DROP AND SEIZURE OF THE ROTATING ALTERNATOR SHAFT AND PULLEY. ONCE THE PULLEY IS STATIONARY, THE ALTERNATOR DRIVE BELT CONTINUES TO PASS OVER THE PULLEY CREATING HIGH QUANTITIES OF BELT DUST. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH GRAHAM WHITE AIR DRYERS, THE AIR DRYER TIMER MODULES MAY ALLOW SUFFICIENT QUANTITIES OF MOISTURE TO ENTER AND AFFECT THE OPERATION OF THE VEHICLE AIR BRAKE SYSTEM. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2007-2011 LOW FLOOR TRANSIT BUSES PRODUCED FROM MAY 24, 2007, THROUGH MARCH 1, 2011 AND EQUIPPED WITH TEETER LEVER ASSEMBLIES. THERE IS INSUFFICIENT ENGAGEMENT BETWEEN THE TEETER LEVER BASE AND THE CAM PLATE. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2005-2010 HEAVY DUTY TRANSIT BUSES. THE THREE RETAINING BOLTS FOR THE OUTPUT FLANGE ON THE ISE PROPULSION SYSTEM ARE SUBJECT TO FATIGUE FAILURE. FAILURE OF THE THREE BOLTS RETAINING THE OUTPUT FLANGE TO THE COMBINATION GEAR BOX ON THE ISE PROPULSION SYSTEM COULD RESULT IN A SEPARATION OF A PORTION OF THE DRIVESHAFT, WITH THE OUTPUT FLANGE ATTACHED, FROM THE VEHICLE. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2004-2009 TRANSIT BUSES. THESE MODELS HAVE AN INSPECTION PANEL LOCATED ABOVE THE DRIVE SHAFT IN THE PASSENGER COMPARTMENT FLOORING FOR EASY INSPECTION AND REMOVAL OF THE DRIVE SHAFT. THIS PANEL MAY NOT BE OF SUFFICIENT STRENGTH TO PREVENT FOREIGN MATTER FROM ENTERING THE PASSENGER COMPARTMENT IN THE EVENT OF A DRIVE SHAFT FAILURE. Recall Details
Problem: New Flyer is recalling certain model year 2004-2011 transit buses, models: C35LF, C40LFR, D35LFR, D40LF, D40LFR, D60LF, D60LFA, D60LFR, DE35LFA, DE40LF, DE40LFA, DE40LFR, DE60LF, DE60LFA, DE60LFR, and XDE40. The drive shaft access panel may have insufficient strength or be not properly secured to the floor. If the drive shaft fails, debris from the driveshaft failure may enter the passenger compartment through the panel. Recall Details
Problem: New Flyer Industries Ltd (New Flyer) is recalling certain 2006 L40LFand DE60LF transit buses, 2006-2007 C35LF, C40LFR, D35LF, D40LFR, D60LFR, DE40LF and DE40LFR transit buses, and 2005-2007 C40LF, D40LF, D60LF, DE60LFA, GE40LF, 2007 D35LFR, and DE60LFR transit buses. These vehicles are equipped with MAN V8-65L axle beams that may have cracks on the upper and/or lower surface, which, over time can cause the axle beam to fail. Recall Details
Problem: New Flyer Industries Ltd (New Flyer) is recalling certain 2006 L40LFand DE60LF transit buses, 2006-2007 C35LF, C40LFR, D35LF, D40LFR, D60LFR, DE40LF and DE40LFR transit buses, and 2005-2007 C40LF, D40LF, D60LF, DE60LFA, GE40LF, 2007 D35LFR, and DE60LFR transit buses. These vehicles are equipped with MAN V8-65L axle beams that may have cracks on the upper and/or lower surface, which, over time can cause the axle beam to fail. Recall Details
Problem: New Flyer is recalling certain model year 2004-2011 transit buses, models: C35LF, C40LFR, D35LFR, D40LF, D40LFR, D60LF, D60LFA, D60LFR, DE35LFA, DE40LF, DE40LFA, DE40LFR, DE60LF, DE60LFA, DE60LFR, and XDE40. The drive shaft access panel may have insufficient strength or be not properly secured to the floor. If the drive shaft fails, debris from the driveshaft failure may enter the passenger compartment through the panel. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2004-2009 TRANSIT BUSES. THESE MODELS HAVE AN INSPECTION PANEL LOCATED ABOVE THE DRIVE SHAFT IN THE PASSENGER COMPARTMENT FLOORING FOR EASY INSPECTION AND REMOVAL OF THE DRIVE SHAFT. THIS PANEL MAY NOT BE OF SUFFICIENT STRENGTH TO PREVENT FOREIGN MATTER FROM ENTERING THE PASSENGER COMPARTMENT IN THE EVENT OF A DRIVE SHAFT FAILURE. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: CERTAIN BUSES HAVE STAINLESS STEEL HYDRAULIC LINES WITH 90? FLANGE FITTINGS WHICH ARE SUBJECT TO FAILURE DUE TO ERRORS IN BOTH THE DESIGN AND MANUFACTURE OF THESE LINES. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH GRAHAM WHITE AIR DRYERS, THE AIR DRYER TIMER MODULES MAY ALLOW SUFFICIENT QUANTITIES OF MOISTURE TO ENTER AND AFFECT THE OPERATION OF THE VEHICLE AIR BRAKE SYSTEM. Recall Details
Problem: NEW FLYER IS RECALLING 1,001 MY 2004-2007 D40LF, MY 2005 D40LFR, AND MY 2007-2008 D60LFR TRANSIT BUSES EQUIPPED WITH CE NIEHOFF C701A OR C703A ALTERNATORS. FAILURE OF THE FORWARD ALTERNATOR BEARING MAY RESULT IN A DROP AND SEIZURE OF THE ROTATING ALTERNATOR SHAFT AND PULLEY. ONCE THE PULLEY IS STATIONARY, THE ALTERNATOR DRIVE BELT CONTINUES TO PASS OVER THE PULLEY CREATING HIGH QUANTITIES OF BELT DUST. Recall Details
Problem: ON CERTAIN TRANSIT BUSES BUILT WITH CUMMINS ISL AND ISC DIESEL ENGINES EQUIPPED WITH THE CM850 FUEL SYSTEM, THE ENGINE HIGH PRESSURE FUEL LINES, FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL, ARE PRONE TO FAILURE. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, THE SPOT WELDS WHICH HOLD THE WHEELCHAIR RAMP HINGE ASSEMBLY TOGETHER CAN FAIL ALLOWING THE RAMP TO SEPARATE, WHEN DEPLOYED UNDER LOAD, FROM THE BUS FRAME. Recall Details
Problem: ON CERTAIN TRANSIT BUSES BUILT WITH CUMMINS ISL AND ISC DIESEL ENGINES EQUIPPED WITH THE CM850 FUEL SYSTEM, THE ENGINE HIGH PRESSURE FUEL LINES, FROM THE ENGINE HIGH PRESSURE PUMP TO THE ENGINE FUEL RAIL, ARE PRONE TO FAILURE. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, HYDRAULIC FLUID CAN LEAK AT THE FLANGE FITTING DUE TO IMPROPER INSTALLATION PROCEDURES. INCORRECT INSTALLATION PROCEDURES MAY CAUSE DAMAGE TO THE O-RING OF THE FLANGE ASSEMBLY, COMPROMISING THE SEALING CAPABILITY OF THE O-RING. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH RELAY VALVES BUILT BY HALDEX/MIDLAND AND DISTRIBUTED BY MERITOR/WABCO WITH VALVE BODY DATE CODE OF 342A4K. THIS VALVE, WHICH IS INSTALLED IN THE REAR AXLE AIR BRAKE CIRCUIT, CAN FAIL RESULTING IN A LOSS OF AIR PRESSURE TO THE REAR SERVICE BRAKES. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH MERITOR FRONT AXLE ASSEMBLIES, A WELD IS MISSING ON THE RADIUS ROD ATTACHMENT BRACKETAND THE BRACKET MAY FATIGUE AND FAIL WHILE IN USE. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: NEW FLYER IS RECALLING 1,001 MY 2004-2007 D40LF, MY 2005 D40LFR, AND MY 2007-2008 D60LFR TRANSIT BUSES EQUIPPED WITH CE NIEHOFF C701A OR C703A ALTERNATORS. FAILURE OF THE FORWARD ALTERNATOR BEARING MAY RESULT IN A DROP AND SEIZURE OF THE ROTATING ALTERNATOR SHAFT AND PULLEY. ONCE THE PULLEY IS STATIONARY, THE ALTERNATOR DRIVE BELT CONTINUES TO PASS OVER THE PULLEY CREATING HIGH QUANTITIES OF BELT DUST. Recall Details
Problem: New Flyer Industries Ltd (New Flyer) is recalling certain 2006 L40LFand DE60LF transit buses, 2006-2007 C35LF, C40LFR, D35LF, D40LFR, D60LFR, DE40LF and DE40LFR transit buses, and 2005-2007 C40LF, D40LF, D60LF, DE60LFA, GE40LF, 2007 D35LFR, and DE60LFR transit buses. These vehicles are equipped with MAN V8-65L axle beams that may have cracks on the upper and/or lower surface, which, over time can cause the axle beam to fail. Recall Details
Problem: NEW FLYER IS RECALLING 1,001 MY 2004-2007 D40LF, MY 2005 D40LFR, AND MY 2007-2008 D60LFR TRANSIT BUSES EQUIPPED WITH CE NIEHOFF C701A OR C703A ALTERNATORS. FAILURE OF THE FORWARD ALTERNATOR BEARING MAY RESULT IN A DROP AND SEIZURE OF THE ROTATING ALTERNATOR SHAFT AND PULLEY. ONCE THE PULLEY IS STATIONARY, THE ALTERNATOR DRIVE BELT CONTINUES TO PASS OVER THE PULLEY CREATING HIGH QUANTITIES OF BELT DUST. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: ON CERTAIN TRANSIT BUSES CUSTOM BUILT FOR SOUTHEASTERN PENNSYLVANIA TRANSIT AUTHORITY AND EQUIPPED WITH MAN AXLES, THE CENTER-LINK ASSEMBLIES WERE INCORRECTLY TIGHTENED. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH WEBASTO HEATERS, THE BURNER TUBES ARE MADE OF MATERIAL THAT DOES NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH MERITOR FRONT AXLE ASSEMBLIES, A WELD IS MISSING ON THE RADIUS ROD ATTACHMENT BRACKETAND THE BRACKET MAY FATIGUE AND FAIL WHILE IN USE. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, THE SPOT WELDS WHICH HOLD THE WHEELCHAIR RAMP HINGE ASSEMBLY TOGETHER CAN FAIL ALLOWING THE RAMP TO SEPARATE, WHEN DEPLOYED UNDER LOAD, FROM THE BUS FRAME. Recall Details
Problem: ON CERTAIN TRANSIT BUSES MANUFACTURED WITH DETROIT DIESEL SERIES 50 ENGINES, THE ELECTRONIC CONTROL MODULE (ECM) WILL NEED TO BE REPROGRAMMED TO ACTIVATE THE EXHAUST TEMPERATURE SENSOR. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH RELAY VALVES BUILT BY HALDEX/MIDLAND AND DISTRIBUTED BY MERITOR/WABCO WITH VALVE BODY DATE CODE OF 342A4K. THIS VALVE, WHICH IS INSTALLED IN THE REAR AXLE AIR BRAKE CIRCUIT, CAN FAIL RESULTING IN A LOSS OF AIR PRESSURE TO THE REAR SERVICE BRAKES. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, HYDRAULIC FLUID CAN LEAK AT THE FLANGE FITTING DUE TO IMPROPER INSTALLATION PROCEDURES. INCORRECT INSTALLATION PROCEDURES MAY CAUSE DAMAGE TO THE O-RING OF THE FLANGE ASSEMBLY, COMPROMISING THE SEALING CAPABILITY OF THE O-RING. Recall Details
Problem: ON CERTAIN TRANSIT BUSES MANUFACTURED WITH DETROIT DIESEL SERIES 50 ENGINES, THE ELECTRONIC CONTROL MODULE (ECM) WILL NEED TO BE REPROGRAMMED TO ACTIVATE THE EXHAUST TEMPERATURE SENSOR. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH A VOITH TRANSMISSION, THE COOLER LINE CAN RUB ON THE AUXILIARY HEATER EXHAUST. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH WEBASTO HEATERS, THE BURNER TUBES ARE MADE OF MATERIAL THAT DOES NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY. Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: NEW FLYER IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN MAY 2002 AND SEPTEMBER 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH A VOITH TRANSMISSION, THE COOLER LINE CAN RUB ON THE AUXILIARY HEATER EXHAUST. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE. Recall Details
Problem: ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THE CLAMP NUTS FOR THE CENTER LINK TIE RODS MAY HAVE BEEN INADEQUATELY TIGHTENED. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE. Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: ON CERTAIN LOW FLOOR TRANSIT BUSES EQUIPPED WITH ADHESIVELY BONDED ALUMINUM BUS DOOR PANELS, DUE TO AN IMPERFECT BONDING OF THE DOOR PANEL SKIN TO THE PANEL FRAME, ENVIRONMENTAL MOISTURE MAY INFILTRATE REGIONS OF IMPERFECT BONDING AND CAUSE SEPARATION OF THE FRAME AND DOOR PANEL. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THE CLAMP NUTS FOR THE CENTER LINK TIE RODS MAY HAVE BEEN INADEQUATELY TIGHTENED. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THE FRONT AXLE'S SPRING TOWER BOLTS MAY NOT HAVE BEEN ADEQUATELY TIGHTENED. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE. Recall Details
Problem: ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED. Recall Details
Problem: ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE. Recall Details
Problem: VEHICLE DESCRIPTION: CERTAIN TRANSIT BUSES EQUIPPED WITH ABS FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE REAR BRAKE RELEASE TIME CAN EXCEED THE REQUIREMENTS. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THE CLAMP NUTS FOR THE CENTER LINK TIE RODS MAY HAVE BEEN INADEQUATELY TIGHTENED. Recall Details
Problem: ON CERTAIN LOW FLOOR TRANSIT BUSES EQUIPPED WITH ADHESIVELY BONDED ALUMINUM BUS DOOR PANELS, DUE TO AN IMPERFECT BONDING OF THE DOOR PANEL SKIN TO THE PANEL FRAME, ENVIRONMENTAL MOISTURE MAY INFILTRATE REGIONS OF IMPERFECT BONDING AND CAUSE SEPARATION OF THE FRAME AND DOOR PANEL. Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: ON CERTAIN LOW FLOOR TRANSIT BUSES EQUIPPED WITH ADHESIVELY BONDED ALUMINUM BUS DOOR PANELS, DUE TO AN IMPERFECT BONDING OF THE DOOR PANEL SKIN TO THE PANEL FRAME, ENVIRONMENTAL MOISTURE MAY INFILTRATE REGIONS OF IMPERFECT BONDING AND CAUSE SEPARATION OF THE FRAME AND DOOR PANEL. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THERE COULD BE A CASTING DEFECT IN THE LEFT SIDE SPRING TOWER. THE SPRING TOWERS SUPPORT THE VEHICLE STRUCTURE, AND FAILURE OF A TOWER COULD CAUSE A SUDDEN SHIFT IN THE FRONT AXLE. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THE CLAMP NUTS FOR THE CENTER LINK TIE RODS MAY HAVE BEEN INADEQUATELY TIGHTENED. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH VANNER 60 SERIES BATTERY EQUALIZERS. THE EQUALIZER COULD FAIL TO OPERATE PROPERLY AND CAUSE MALFUNCTION OF THE BATTERY CHARGING SYSTEM. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THE REAR BRAKE RELEASE TIME CAN EXCEED THE REQUIREMENTS OF FMVSS NO. 121. Recall Details
Problem: VEHICLE DESCRIPTION: CERTAIN TRANSIT BUSES EQUIPPED WITH ABS FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." THE REAR BRAKE RELEASE TIME CAN EXCEED THE REQUIREMENTS. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE. Recall Details
Problem: ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED. Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. A TETHER STRAP ON THE DRIVER'S SEAT WAS OMITTED. THIS DOES NOT COMPLY WITH THE STRENGTH REQUIREMENTS OF FMVSS NO. 207, SEATING SYSTEMS." Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES EQUIPPED WITH AN AUXILIARY DIESEL POWERED HEATER (PROHEAT BRAVO MODEL 80). AN IMPROPERLY ASSEMBLED FUEL REGULATOR CAN ALLOW AN EXCESS AMOUNT OF FUEL INTO THE COMBUSTION CHAMBER. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THE DAYTIME RUNNING LAMP (DRL) MODULE CAN OVER-HEAT AND SHUT DOWN AFTER AS LITTLE AS 45 MINUTES OF HIGH BEAM USE. THIS WILL CAUSE TOTAL HEADLAMP FAILURE OF BOTH HIGH AND LOW BEAM. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. THERE COULD BE A CASTING DEFECT IN THE LEFT SIDE SPRING TOWER. THE SPRING TOWERS SUPPORT THE VEHICLE STRUCTURE, AND FAILURE OF A TOWER COULD CAUSE A SUDDEN SHIFT IN THE FRONT AXLE. Recall Details
Problem: ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED. Recall Details
Problem: ON CERTAIN LOW FLOOR BUSES, THE POWER STEERING HOSE WAS INCORRECTLY INSTALLED. Recall Details
Problem: VEHICLE DESCRIPTION: BUSES EQUIPPED WITH ISRINGHAUSEN SEATS IN THE DRIVER POSITION. TWO WELDS LOCATED ON THE BACK REST ADJUSTMENT SIDE OF THE SEAT FRAME DID NOT MEET THE MANUFACTURER'S SPECIFICATIONS. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. A TETHER STRAP ON THE DRIVER'S SEAT WAS OMITTED. THIS DOES NOT COMPLY WITH THE STRENGTH REQUIREMENTS OF FMVSS NO. 207, SEATING SYSTEMS." Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: THE BRAKE RELEASE TIMING DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." Recall Details
Problem: THE BRAKE RELEASE TIMING DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. FIVE (5) FRONT RADIUS RODS INSTALLED IN THESE BUSES HAVE FAILED. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. FIVE (5) FRONT RADIUS RODS INSTALLED IN THESE BUSES HAVE FAILED. Recall Details
Problem: THE BRAKE RELEASE TIMING DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." Recall Details
Problem: THE BRAKE RELEASE TIMING DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 121, "AIR BRAKE SYSTEMS." Recall Details
Problem: CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE FLASHING DECELERATION LAMPS WERE AN OPTIONAL ITEM FOR SOME OF THESE BUSES. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES. FIVE (5) FRONT RADIUS RODS INSTALLED IN THESE BUSES HAVE FAILED. Recall Details
Problem: VEHICLE DESCRIPTION: TRANSIT BUSES OWNED BY THE NEW YORK PORT AUTHORITY. THE LEFT FRONT SUSPENSION RADIUS ROD BOLTS DID NOT PROVIDE SUFFICIENT CLAMPING OF THE RADIUS ROD PIN CAUSING THE PIN TO ROTATE IN ITS MOUNTING BLOCKS LEADING TO BOLT FAILURE. Recall Details
|