|
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2011-2012 Orion VII transit buses equipped with disc brakes using MGM brake components. In the affected vehicles, the brake chambers may leak pressure allowing the parking brake to drag when it is supposed to be released. Brake dragging could lead to overheated brake components. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII transit buses manufactured January 2007 through October 2012 equipped with certain Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII natural gas-powered transit buses manufactured January 1, 2007, to October 1, 2012. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2010-2012 Orion VII transit buses manufactured April 5, 2010, to October 31, 2012, equipped with certain Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII natural gas-powered transit buses manufactured January 1, 2007, to October 1, 2012. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2010-2012 Orion VII transit buses manufactured April 5, 2010, to October 31, 2012, equipped with certain Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII transit buses manufactured January 2007 through October 2012 equipped with certain Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2011-2012 Orion VII transit buses equipped with disc brakes using MGM brake components. In the affected vehicles, the brake chambers may leak pressure allowing the parking brake to drag when it is supposed to be released. Brake dragging could lead to overheated brake components. Recall Details
Problem: DAIMLER BUSES NORTH AMERICA (DBNA) IS RECALLING CERTAIN MODEL YEAR 2010 ORION VII TRANSIT BUSES MANUFACTURED FROM NOVEMBER 2010 THROUGH JANUARY 2011, EQUIPPED WITH A CUMMINS ISB, ISX, ISC, OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII natural gas-powered transit buses manufactured January 1, 2007, to October 1, 2012. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII transit buses manufactured January 2007 through October 2012 equipped with certain Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2010-2012 Orion VII transit buses manufactured April 5, 2010, to October 31, 2012, equipped with certain Recaro Ergo-M Commercial Bus Driver Seats. The affected seats have J-Brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the J-Bracket. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII transit buses manufactured January 2007 through October 2012 equipped with certain Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII natural gas-powered transit buses manufactured January 1, 2007, to October 1, 2012. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER. Recall Details
Problem: DAIMLER BUSES IS RECALLING 380 MY 2008-2009 VII BUSES CONFIGURED WITH A MOBILE CLIMATE CONTROL (MCC) HEATER AND THOSE WITH A MCC DEFROSTER MANUFACTURER FROM OCTOBER 2008 - MARCH 2009 ONLY. THE BLOWER MOTOR MOUNT SCREWS MAY NOT HAVE THE PROPER TORQUE. IF THE FOUR BLOWER MOTOR MOUNT SCREWS DISCONNECT, THE BRACKET CAN MOVE POSSIBLY CAUSING AN ELECTRICAL TERMINAL SHORT CIRCUIT. Recall Details
Problem: ORION IS RECALLING 286 MODEL YEAR 2007 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 2007 AND APRIL 2009. THE BOND OF THE GLASS TO THE ALUMINUM FRAME OF THE PASSENGER WINDOWS IS NOT ADEQUATE ENOUGH TO HOLD THE WINDOW ATTACHED TO THE FRAME. Recall Details
Problem: DAIMLER BUS NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 ORION VII TRANSIT BUSES MANUFACTURED FROM DECEMBER 2007 THROUGH JULY 2009. THE PASSENGER WINDOWS HAVE A TIP-IN TRANSOM WINDOW WHICH IS ATTACHED BY SCREWS. THESE SCREWS MAY LOOSEN AND THE WINDOW MAY DISLODGE AND FALL INTO THE BUS. Recall Details
Problem: DAIMLER BUS NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 ORION VII TRANSIT BUSES MANUFACTURED FROM DECEMBER 2007 THROUGH JULY 2009. THE PASSENGER WINDOWS HAVE A TIP-IN TRANSOM WINDOW WHICH IS ATTACHED BY SCREWS. THESE SCREWS MAY LOOSEN AND THE WINDOW MAY DISLODGE AND FALL INTO THE BUS. Recall Details
Problem: ORION IS RECALLING 286 MODEL YEAR 2007 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 2007 AND APRIL 2009. THE BOND OF THE GLASS TO THE ALUMINUM FRAME OF THE PASSENGER WINDOWS IS NOT ADEQUATE ENOUGH TO HOLD THE WINDOW ATTACHED TO THE FRAME. Recall Details
Problem: DAIMLER BUS IS RECALLING 804 MY 2006-2009 TRANSIT BUSES EQUIPPED WITH A NEW YORK CUSTOM SEAT HEATER. CURRENTLY, THE TERMINAL CONNECTION OF THE SEAT HEATER IS IMMEDIATELY LOCATED NEXT TO THE SEAT BUS BAR. SHOULD CONDUCTIVE MATERIAL OR DEBRIS, SUCH AS A WASHER, ENTER BETWEEN THE TERMINAL CONNECTION AND THE SEAT BUS BAR, A SHORT CIRCUIT COULD OCCUR. Recall Details
Problem: DAIMLER BUSES IS RECALLING 380 MY 2008-2009 VII BUSES CONFIGURED WITH A MOBILE CLIMATE CONTROL (MCC) HEATER AND THOSE WITH A MCC DEFROSTER MANUFACTURER FROM OCTOBER 2008 - MARCH 2009 ONLY. THE BLOWER MOTOR MOUNT SCREWS MAY NOT HAVE THE PROPER TORQUE. IF THE FOUR BLOWER MOTOR MOUNT SCREWS DISCONNECT, THE BRACKET CAN MOVE POSSIBLY CAUSING AN ELECTRICAL TERMINAL SHORT CIRCUIT. Recall Details
Problem: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER. Recall Details
Problem: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: DAIMLER BUSES IS RECALLING CERTAIN MODEL YEAR 2008 ORION VII TRANSIT BUSES MANUFACTURED FROM JUNE 13-16, 2008, AND EQUIPPED WITH TEETER LEVER ASSEMBLIES. THERE IS INSUFFICIENT ENGAGEMENT BETWEEN THE TEETER LEVER BASE AND THE CAM PLATE. Recall Details
Problem: DAIMLER BUSES IS RECALLING 175 MY 2004-2008 ORION V AND VII BUSES EQUIPPED WITH A CUMMINS ISL DIESEL ENGINES. DUE TO VARIOUS ALTERNATOR CABLE ROUTING CONFIGURATIONS, IT MAY BE POSSIBLE FOR THE CABLE TO RUB ON ENGINE COMPONENTS. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII natural gas-powered transit buses manufactured January 1, 2007, to October 1, 2012. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII transit buses manufactured January 2007 through October 2012 equipped with certain Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII transit buses manufactured January 2007 through October 2012 equipped with certain Cummins Westport Model ISL G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2007-2012 Orion VII natural gas-powered transit buses manufactured January 1, 2007, to October 1, 2012. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces. Recall Details
Problem: DAIMLER BUSES IS RECALLING 175 MY 2004-2008 ORION V AND VII BUSES EQUIPPED WITH A CUMMINS ISL DIESEL ENGINES. DUE TO VARIOUS ALTERNATOR CABLE ROUTING CONFIGURATIONS, IT MAY BE POSSIBLE FOR THE CABLE TO RUB ON ENGINE COMPONENTS. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS ENGINES CONFIGURED WITH DIESEL PARTICULATE FILTERS (DPF) AND ULTRA COMPACT MODULES (UCM), THE UCM MAY FAIL. THE UCM IS LOCATED IN A WIRING HARNESS INSIDE THE ENGINE COMPARTMENT ON THE CURB SIDE. Recall Details
Problem: ON CERTAIN TRANSIT BUSES BUILT WITH CUMMINS ISL ENGINES, THE EXHAUST ELBOW WAS INCORRECTLY ASSEMBLED AND WELDED DURING PRODUCTION. THE UPPER FLANGE HAS A BUTT TYPE WELD INSTEAD OF A FILLET TYPE WELD. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: ORION IS RECALLING 286 MODEL YEAR 2007 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 2007 AND APRIL 2009. THE BOND OF THE GLASS TO THE ALUMINUM FRAME OF THE PASSENGER WINDOWS IS NOT ADEQUATE ENOUGH TO HOLD THE WINDOW ATTACHED TO THE FRAME. Recall Details
Problem: DAIMLER BUS IS RECALLING 804 MY 2006-2009 TRANSIT BUSES EQUIPPED WITH A NEW YORK CUSTOM SEAT HEATER. CURRENTLY, THE TERMINAL CONNECTION OF THE SEAT HEATER IS IMMEDIATELY LOCATED NEXT TO THE SEAT BUS BAR. SHOULD CONDUCTIVE MATERIAL OR DEBRIS, SUCH AS A WASHER, ENTER BETWEEN THE TERMINAL CONNECTION AND THE SEAT BUS BAR, A SHORT CIRCUIT COULD OCCUR. Recall Details
Problem: DAIMLER BUS NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 ORION VII TRANSIT BUSES MANUFACTURED FROM DECEMBER 2007 THROUGH JULY 2009. THE PASSENGER WINDOWS HAVE A TIP-IN TRANSOM WINDOW WHICH IS ATTACHED BY SCREWS. THESE SCREWS MAY LOOSEN AND THE WINDOW MAY DISLODGE AND FALL INTO THE BUS. Recall Details
Problem: DAIMLER BUS NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 ORION VII TRANSIT BUSES MANUFACTURED FROM DECEMBER 2007 THROUGH JULY 2009. THE PASSENGER WINDOWS HAVE A TIP-IN TRANSOM WINDOW WHICH IS ATTACHED BY SCREWS. THESE SCREWS MAY LOOSEN AND THE WINDOW MAY DISLODGE AND FALL INTO THE BUS. Recall Details
Problem: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2004-2008 Orion V and model year 2005-2006 Orion VII transit buses equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak. Recall Details
Problem: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER. Recall Details
Problem: ON CERTAIN TRANSIT BUSES BUILT WITH CUMMINS ISL ENGINES, THE EXHAUST ELBOW WAS INCORRECTLY ASSEMBLED AND WELDED DURING PRODUCTION. THE UPPER FLANGE HAS A BUTT TYPE WELD INSTEAD OF A FILLET TYPE WELD. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS ENGINES CONFIGURED WITH DIESEL PARTICULATE FILTERS (DPF) AND ULTRA COMPACT MODULES (UCM), THE UCM MAY FAIL. THE UCM IS LOCATED IN A WIRING HARNESS INSIDE THE ENGINE COMPARTMENT ON THE CURB SIDE. Recall Details
Problem: DAIMLER BUSES IS RECALLING 175 MY 2004-2008 ORION V AND VII BUSES EQUIPPED WITH A CUMMINS ISL DIESEL ENGINES. DUE TO VARIOUS ALTERNATOR CABLE ROUTING CONFIGURATIONS, IT MAY BE POSSIBLE FOR THE CABLE TO RUB ON ENGINE COMPONENTS. Recall Details
Problem: DAIMLER BUS IS RECALLING 804 MY 2006-2009 TRANSIT BUSES EQUIPPED WITH A NEW YORK CUSTOM SEAT HEATER. CURRENTLY, THE TERMINAL CONNECTION OF THE SEAT HEATER IS IMMEDIATELY LOCATED NEXT TO THE SEAT BUS BAR. SHOULD CONDUCTIVE MATERIAL OR DEBRIS, SUCH AS A WASHER, ENTER BETWEEN THE TERMINAL CONNECTION AND THE SEAT BUS BAR, A SHORT CIRCUIT COULD OCCUR. Recall Details
Problem: DAIMLER BUSES IS RECALLING 175 MY 2004-2008 ORION V AND VII BUSES EQUIPPED WITH A CUMMINS ISL DIESEL ENGINES. DUE TO VARIOUS ALTERNATOR CABLE ROUTING CONFIGURATIONS, IT MAY BE POSSIBLE FOR THE CABLE TO RUB ON ENGINE COMPONENTS. Recall Details
Problem: ON CERTAIN TRANSIT BUSES BUILT WITH CUMMINS ISL ENGINES, THE EXHAUST ELBOW WAS INCORRECTLY ASSEMBLED AND WELDED DURING PRODUCTION. THE UPPER FLANGE HAS A BUTT TYPE WELD INSTEAD OF A FILLET TYPE WELD. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS ISB-02 DIESEL ENGINES BUILT WITH EMC CONTROLLED FUEL LIFT PUMPS. ERRATIC VOLTAGE SUPPLY TO THE FUEL LIFT PUMP CAUSES PREMATURE ELECTRIC BRUSH WEAR INTERNAL TO THE FUEL LIFT PUMP. THIS PREMATURE WEAR COULD RESULT IN FUEL LIFT PUMP FAILURE AND IN SOME CASES MAY CAUSE AN ENGINE STALL CONDITION. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH A GRAHAM WHITE BRAKE AIR DRYER MODEL QBA15, THE BRAKE AIR DRYER TIMER DOES NOT FUNCTION PROPERLY. THE AIR ENTERING INTO THE BRAKE SYSTEM MAY NOT HAVE THE MOISTURE REMOVED. IF NOT PROPERLY DRAINED, SMALL ICE CRYSTALS MAY FORM IN THE BRAKE SYSTEM PREVENTING THE SYSTEM TO OPERATE THE BRAKES PROPERLY. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH CONFIGURATION FC510 HIGH PRESSURE FAN MOTOR HOSES, THE WRONG HOSE SPECIFICATION WAS SELECTED. Recall Details
Problem: ON CERTAIN TRANSIT BUSSES EQUIPPED WITH ARVINMERITOR URRESKO TIE ROD CLAMPS, HEAT TREATMENT OF CLAMPS CREATED A SURFACE HARDNESS THAT COULD LEAD TO A FRACTURE OF THE CLAMPS. Recall Details
Problem: ON CERTAIN COMMERCIAL BUSES EQUIPPED WITH VAPOR DOOR ASSEMBLIES, THE TWO PIECE CURVED CONNECTING RODS WHEN USED AS AN ELEMENT OF THE DOOR ACTUATION LINKAGE IN CONJUNCTION WITH A VAPOR MEDIUM PNEUMATIC DIFFERENTIAL ENGINE, MAY BE SUBJECT TO FATIGUE FAILURE RESULTING IN BENDING OR BREAKING OF THE CONNECTING ROD. Recall Details
Problem: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER. Recall Details
Problem: Daimler Buses North America (DBNA) is recalling certain model year 2004-2008 Orion V and model year 2005-2006 Orion VII transit buses equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak. Recall Details
Problem: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, THE FUEL LIFT PUMP COULD FAIL IN A MANNER WHICH RESULTS IN ENGINE FUEL STARVATION, WHICH COULD RESULT IN A STALL CONDITION. POTENTIAL LIFT PUMP FAILURE MODES INCLUDE: BRUSH WEAR OUT, BUSHING FAILURE, ROTOR TAB INSERT FAILURE, OR ANY OTHER FAILURE MODE THAT WOULD CAUSE THE FUEL PUMPING ELEMENT TO STOP SPINNING. Recall Details
Problem: ON CERTAIN COMMERCIAL BUSES EQUIPPED WITH VAPOR DOOR ASSEMBLIES, THE TWO PIECE CURVED CONNECTING RODS WHEN USED AS AN ELEMENT OF THE DOOR ACTUATION LINKAGE IN CONJUNCTION WITH A VAPOR MEDIUM PNEUMATIC DIFFERENTIAL ENGINE, MAY BE SUBJECT TO FATIGUE FAILURE RESULTING IN BENDING OR BREAKING OF THE CONNECTING ROD. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS ISB-02 DIESEL ENGINES BUILT WITH EMC CONTROLLED FUEL LIFT PUMPS. ERRATIC VOLTAGE SUPPLY TO THE FUEL LIFT PUMP CAUSES PREMATURE ELECTRIC BRUSH WEAR INTERNAL TO THE FUEL LIFT PUMP. THIS PREMATURE WEAR COULD RESULT IN FUEL LIFT PUMP FAILURE AND IN SOME CASES MAY CAUSE AN ENGINE STALL CONDITION. Recall Details
Problem: ON CERTAIN TRANSIT BUSSES EQUIPPED WITH ARVINMERITOR URRESKO TIE ROD CLAMPS, HEAT TREATMENT OF CLAMPS CREATED A SURFACE HARDNESS THAT COULD LEAD TO A FRACTURE OF THE CLAMPS. Recall Details
Problem: ON CERTAIN BUSES, THE BATTERY STORAGE SLIDING TRAY LOCKING TOGGLE WAS NOT TIGHTENED SUFFICIENTLY. THE BATTERY DOOR CAN OPEN ALLOWING THE BATTERY TRAY TO SLIDE OUT FROM THE STORED POSITION. Recall Details
Problem: ON CERTAIN BUSES, THE ASSEMBLY OF THE WALKING BEAM CONNECTION TO THE REAR SUSPENSION EXHIBITS LOOSE OR BREAKING OF BOLTS DUE TO MISALIGNED SPACERS. Recall Details
Problem: ON CERTAIN TRANSIT BUSES BUILT WITH CUMMINS ISL ENGINES, THE EXHAUST ELBOW WAS INCORRECTLY ASSEMBLED AND WELDED DURING PRODUCTION. THE UPPER FLANGE HAS A BUTT TYPE WELD INSTEAD OF A FILLET TYPE WELD. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH A GRAHAM WHITE BRAKE AIR DRYER MODEL QBA15, THE BRAKE AIR DRYER TIMER DOES NOT FUNCTION PROPERLY. THE AIR ENTERING INTO THE BRAKE SYSTEM MAY NOT HAVE THE MOISTURE REMOVED. IF NOT PROPERLY DRAINED, SMALL ICE CRYSTALS MAY FORM IN THE BRAKE SYSTEM PREVENTING THE SYSTEM TO OPERATE THE BRAKES PROPERLY. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS ENGINES CONFIGURED WITH DIESEL PARTICULATE FILTERS (DPF) AND ULTRA COMPACT MODULES (UCM), THE UCM MAY FAIL. THE UCM IS LOCATED IN A WIRING HARNESS INSIDE THE ENGINE COMPARTMENT ON THE CURB SIDE. Recall Details
Problem: DAIMLER BUSES IS RECALLING 175 MY 2004-2008 ORION V AND VII BUSES EQUIPPED WITH A CUMMINS ISL DIESEL ENGINES. DUE TO VARIOUS ALTERNATOR CABLE ROUTING CONFIGURATIONS, IT MAY BE POSSIBLE FOR THE CABLE TO RUB ON ENGINE COMPONENTS. Recall Details
Problem: CERTAIN BUSES EQUIPPED WITH COMPRESSED NATURAL GAS FUEL CONTAINERS, MODEL ALT823D, P/N 1273147, DO NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 304, 'COMPRESSED NATURAL GAS FUEL CONTAINER INTEGRITY.' THE NGV CONTAINER'S PRESSURE RELIEF DEVICES FAIL TO TIMELY AND FULLY ACTIVATE AS REQUIRED BY THE STANDARD. Recall Details
Problem: ON CERTAIN BUSES, THE BATTERY STORAGE SLIDING TRAY LOCKING TOGGLE WAS NOT TIGHTENED SUFFICIENTLY. THE BATTERY DOOR CAN OPEN ALLOWING THE BATTERY TRAY TO SLIDE OUT FROM THE STORED POSITION. Recall Details
Problem: ON CERTAIN COMMERCIAL BUSES EQUIPPED WITH VAPOR DOOR ASSEMBLIES, THE TWO PIECE CURVED CONNECTING RODS WHEN USED AS AN ELEMENT OF THE DOOR ACTUATION LINKAGE IN CONJUNCTION WITH A VAPOR MEDIUM PNEUMATIC DIFFERENTIAL ENGINE, MAY BE SUBJECT TO FATIGUE FAILURE RESULTING IN BENDING OR BREAKING OF THE CONNECTING ROD. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, THE FUEL LIFT PUMP COULD FAIL IN A MANNER WHICH RESULTS IN ENGINE FUEL STARVATION, WHICH COULD RESULT IN A STALL CONDITION. POTENTIAL LIFT PUMP FAILURE MODES INCLUDE: BRUSH WEAR OUT, BUSHING FAILURE, ROTOR TAB INSERT FAILURE, OR ANY OTHER FAILURE MODE THAT WOULD CAUSE THE FUEL PUMPING ELEMENT TO STOP SPINNING. Recall Details
Problem: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER. Recall Details
Problem: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: DAIMLER BUSES OF NORTH AMERICA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 ORION TRANSIT BUSES EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER. Recall Details
Problem: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat. Recall Details
Problem: ON CERTAIN COMMERCIAL BUSES EQUIPPED WITH VAPOR DOOR ASSEMBLIES, THE TWO PIECE CURVED CONNECTING RODS WHEN USED AS AN ELEMENT OF THE DOOR ACTUATION LINKAGE IN CONJUNCTION WITH A VAPOR MEDIUM PNEUMATIC DIFFERENTIAL ENGINE, MAY BE SUBJECT TO FATIGUE FAILURE RESULTING IN BENDING OR BREAKING OF THE CONNECTING ROD. Recall Details
Problem: CERTAIN BUSES EQUIPPED WITH COMPRESSED NATURAL GAS FUEL CONTAINERS, MODEL ALT823D, P/N 1273147, DO NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 304, 'COMPRESSED NATURAL GAS FUEL CONTAINER INTEGRITY.' THE NGV CONTAINER'S PRESSURE RELIEF DEVICES FAIL TO TIMELY AND FULLY ACTIVATE AS REQUIRED BY THE STANDARD. Recall Details
Problem: ON CERTAIN BUSES, THE BATTERY STORAGE SLIDING TRAY LOCKING TOGGLE WAS NOT TIGHTENED SUFFICIENTLY. THE BATTERY DOOR CAN OPEN ALLOWING THE BATTERY TRAY TO SLIDE OUT FROM THE STORED POSITION. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, THE FUEL LIFT PUMP COULD FAIL IN A MANNER WHICH RESULTS IN ENGINE FUEL STARVATION, WHICH COULD RESULT IN A STALL CONDITION. POTENTIAL LIFT PUMP FAILURE MODES INCLUDE: BRUSH WEAR OUT, BUSHING FAILURE, ROTOR TAB INSERT FAILURE, OR ANY OTHER FAILURE MODE THAT WOULD CAUSE THE FUEL PUMPING ELEMENT TO STOP SPINNING. Recall Details
Problem: ON CERTAIN COMMERCIAL BUSES EQUIPPED WITH VAPOR DOOR ASSEMBLIES, THE TWO PIECE CURVED CONNECTING RODS WHEN USED AS AN ELEMENT OF THE DOOR ACTUATION LINKAGE IN CONJUNCTION WITH A VAPOR MEDIUM PNEUMATIC DIFFERENTIAL ENGINE, MAY BE SUBJECT TO FATIGUE FAILURE RESULTING IN BENDING OR BREAKING OF THE CONNECTING ROD. Recall Details
|