|
Problem: Champion Bus, Inc. (Champion) is recalling certain 2019 Challenger, Crusader, Defender and LF Transport and Goshen G-Force, Impulse and Pacer II shuttle buses equipped with Prolo roof emergency escape hatches. Due to a manufacturing issue, the roof hatch external handle may unexpectedly break under reasonable use. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain 2017-2018 Champion Challenger, Defender, LF Transport, Goshen G-Force, and Impulse transit buses, equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems," and number 210, "Seat Belt Assembly Anchorages." Recall Details
Problem: Champion Bus (Champion) is recalling certain 2012-2018 Champion American Coach, American Crusader, American S2, Challenger, Crusader, Defender, and Impulse vehicles, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain 2017-2018 Champion Challenger, Defender, LF Transport, Goshen G-Force, and Impulse transit buses, equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems," and number 210, "Seat Belt Assembly Anchorages." Recall Details
Problem: Champion Bus (Champion) is recalling certain 2012-2018 Champion American Coach, American Crusader, American S2, Challenger, Crusader, Defender, and Impulse vehicles, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. Recall Details
Problem: Champion Bus (Champion) is recalling certain 2012-2018 Champion American Coach, American Crusader, American S2, Challenger, Crusader, Defender, and Impulse vehicles, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2016 Champion Bus Challenger shuttle buses manufactured January 29, 2016, to April 4, 2016. These vehicles are equipped with seats that may separate from the base frame due to bolt failure. As such, these seats fail to comply with the requirements of Federal Motor Vehicle Safety System (FMVSS) number 222, "School Bus Passenger Seating and Crash Protection." Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2013-2015 American Crusader, American Coach, Challenger, Crusader, CTS-FE, CTS-RE, Defender, EZ Trans, HCAC, HC, DFUC, LF Transport, Premier, and Spirit transit buses manufactured March 1, 2013, to June 12, 2015. In the affected vehicles, the passenger seat belts may rub against the metal seat frame and fray. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies." Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2014-2015 LF Transport, HCAC, Defender, Crusader, and Challenger transit buses manufactured September 2, 2014, to October 14, 2014. The spring nuts used to secure the passenger seats failed durability testing. Recall Details
Problem: Champion Bus (Champion) is recalling certain 2012-2018 Champion American Coach, American Crusader, American S2, Challenger, Crusader, Defender, and Impulse vehicles, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2014-2015 LF Transport, HCAC, Defender, Crusader, and Challenger transit buses manufactured September 2, 2014, to October 14, 2014. The spring nuts used to secure the passenger seats failed durability testing. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2012-2014 American Crusader, Challenger, Crusader, CTS-FE, CTS-RE, Defender, EZ-Street, HC American, HCAC, LF Transport, M1235, Platinum Shuttle, Stacked Rail, and Federal Coach Premier, and Spirit transit buses manufactured January 1, 2012, to October 1, 2014, equipped with certain triangle warning signs manufactured by Imperial Supplies, LLC. Test reports indicate that the triangle warning signs, labeled C&J, may reflect an inadequate amount of light. As such, these triangle warning kits fail to comply with Federal Motor Vehicle Safety Standard No. 125, "Warning devices." Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2013-2015 American Crusader, American Coach, Challenger, Crusader, CTS-FE, CTS-RE, Defender, EZ Trans, HCAC, HC, DFUC, LF Transport, Premier, and Spirit transit buses manufactured March 1, 2013, to June 12, 2015. In the affected vehicles, the passenger seat belts may rub against the metal seat frame and fray. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies." Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus (Champion) is recalling certain 2012-2018 Champion American Coach, American Crusader, American S2, Challenger, Crusader, Defender, and Impulse vehicles, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. Recall Details
Problem: Champion Bus (Champion) is recalling certain 2012-2018 Champion American Coach, American Crusader, American S2, Challenger, Crusader, Defender, and Impulse vehicles, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2013-2015 American Crusader, American Coach, Challenger, Crusader, CTS-FE, CTS-RE, Defender, EZ Trans, HCAC, HC, DFUC, LF Transport, Premier, and Spirit transit buses manufactured March 1, 2013, to June 12, 2015. In the affected vehicles, the passenger seat belts may rub against the metal seat frame and fray. As a result, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies." Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2012-2014 American Crusader, Challenger, Crusader, CTS-FE, CTS-RE, Defender, EZ-Street, HC American, HCAC, LF Transport, M1235, Platinum Shuttle, Stacked Rail, and Federal Coach Premier, and Spirit transit buses manufactured January 1, 2012, to October 1, 2014, equipped with certain triangle warning signs manufactured by Imperial Supplies, LLC. Test reports indicate that the triangle warning signs, labeled C&J, may reflect an inadequate amount of light. As such, these triangle warning kits fail to comply with Federal Motor Vehicle Safety Standard No. 125, "Warning devices." Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2013 Challenger transit buses manufactured January 7, 2013, through October 25, 2013, and equipped with certain Ricon S series and K series wheelchair lifts and an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift. Recall Details
Problem: Champion Bus is recalling certain model year 2006, and certain model year 2008-2013 buses, models: American Crusader, Challenger, Crusader, and Defender; manufactured September 30, 2006, through November 16, 2012. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover. Recall Details
Problem: Champion Bus is recalling certain model year 2006, and certain model year 2008-2013 buses, models: American Crusader, Challenger, Crusader, and Defender; manufactured September 30, 2006, through November 16, 2012. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover. Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2012-2014 American Crusader, Challenger, Crusader, CTS-FE, CTS-RE, Defender, EZ-Street, HC American, HCAC, LF Transport, M1235, Platinum Shuttle, Stacked Rail, and Federal Coach Premier, and Spirit transit buses manufactured January 1, 2012, to October 1, 2014, equipped with certain triangle warning signs manufactured by Imperial Supplies, LLC. Test reports indicate that the triangle warning signs, labeled C&J, may reflect an inadequate amount of light. As such, these triangle warning kits fail to comply with Federal Motor Vehicle Safety Standard No. 125, "Warning devices." Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus (Champion) is recalling certain 2012-2018 Champion American Coach, American Crusader, American S2, Challenger, Crusader, Defender, and Impulse vehicles, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: Champion Bus is recalling certain model year 2006, and certain model year 2008-2013 buses, models: American Crusader, Challenger, Crusader, and Defender; manufactured September 30, 2006, through November 16, 2012. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN VEHICLES EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN VEHICLES EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND/OR VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED. Recall Details
Problem: Champion Bus is recalling certain model year 2006, and certain model year 2008-2013 buses, models: American Crusader, Challenger, Crusader, and Defender; manufactured September 30, 2006, through November 16, 2012. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover. Recall Details
Problem: Champion Bus is recalling certain model year 2010 American Crusader, American Coach, CTS-FE, CTS-RE, and IC Low Floor buses; and 2009-2010 Challenger and Crusader buses; and 2009-2011 Defender and EZ Trans buses; and 2010-2011 IC High Floor buses. The buses are manufactured from August 1, 2009, through May 19, 2011, and equipped with A&M Systems door headers containing model 3230 circuit boards. Voltage spikes may damage electrical components and electrical circuits, causing the circuit board to develop high resistance. Recall Details
Problem: CHAMPION BUS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2007-2010 BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM. Recall Details
Problem: CHAMPION BUS HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2008-2010 BUSES MANUFACTURED BETWEEN SEPTEMBER 2007 AND FEBRUARY 2010, EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS, DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT. Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: CHAMPION BUS HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2008-2010 BUSES MANUFACTURED BETWEEN SEPTEMBER 2007 AND FEBRUARY 2010, EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS, DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 TRANSIT BUSES MANUFACTURED BETWEEN JANUARY 2003 AND AUGUST 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 TRANSIT BUSES EQUIPPED WITH CARRIER K410 ROOFTOP CONDENSERS. INADEQUATE OVERCURRENT PROTECTION OF ONE OR MORE OF THE FANS IN THE K410 CONDENSER MAY CAUSE OVERHEATING OF THE FAN'S WIRES. Recall Details
Problem: CHAMPION BUS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2006-2010 BUSES EQUIPPED WITH TRANS/AIR AIR CONDITIONING SYSTEMS INSTALLED BETWEEN MAY 2006 AND JUNE 2009. EACH TRANS/AIR SYSTEM COMES WITH AN ELECTRICAL KIT WHICH CONTAINS A RELAY BOARD AND EC PC BOARD WHICH IF IMPROPERLY INSTALLED COULD OVERHEAT. Recall Details
Problem: CHAMPION BUS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2007-2010 BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM. Recall Details
Problem: Champion Bus is recalling certain model year 2010 American Crusader, American Coach, CTS-FE, CTS-RE, and IC Low Floor buses; and 2009-2010 Challenger and Crusader buses; and 2009-2011 Defender and EZ Trans buses; and 2010-2011 IC High Floor buses. The buses are manufactured from August 1, 2009, through May 19, 2011, and equipped with A&M Systems door headers containing model 3230 circuit boards. Voltage spikes may damage electrical components and electrical circuits, causing the circuit board to develop high resistance. Recall Details
Problem: Champion Bus is recalling certain model year 2006, and certain model year 2008-2013 buses, models: American Crusader, Challenger, Crusader, and Defender; manufactured September 30, 2006, through November 16, 2012. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND/OR VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN VEHICLES EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN VEHICLES EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 TRANSIT BUSES EQUIPPED WITH BRAUN CENTURY-2 AND/OR VISTA-2 WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED. Recall Details
Problem: Champion Bus is recalling certain model year 2006, and certain model year 2008-2013 buses, models: American Crusader, Challenger, Crusader, and Defender; manufactured September 30, 2006, through November 16, 2012. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover. Recall Details
Problem: CHAMPION BUS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2007-2010 BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM. Recall Details
Problem: CHAMPION BUS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2006-2010 BUSES EQUIPPED WITH TRANS/AIR AIR CONDITIONING SYSTEMS INSTALLED BETWEEN MAY 2006 AND JUNE 2009. EACH TRANS/AIR SYSTEM COMES WITH AN ELECTRICAL KIT WHICH CONTAINS A RELAY BOARD AND EC PC BOARD WHICH IF IMPROPERLY INSTALLED COULD OVERHEAT. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN BUSES EQUIPPED WITH TRANS AIR TA 73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Recall Details
Problem: CHAMPION BUS IS RECALLING 503 MY 2005-2008 DEFENDER, CHALLENGER, CTS-RE, CTS-FE AND CRUSADER BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA. Recall Details
Problem: CHAMPION BUS IS RECALLING 31 MY 2007-2008 DEFENDER, CHALLENGER AND MY 2008 CRUSADER BUSES BUILT ON GENERAL MOTORS 560 CHASSIS AND EQUIPPED WITH INTERMOTIVE GATEWAY 401 MODULE INTERLOCK HARNESS. THESE BUSES HAVE BEEN FOUND TO EXHIBIT EXTREME VOLTAGE SPIKES DURING ENGINE CRANKING. THESE EXTREME SPIKES CAN DAMAGE THE DIODE IN THE HARNESS NEAR THE SHIFT LOCK SOLENOID CONNECTOR. IF THE DIODE FAILS IN THE SHORTED CONDITION, THE GATEWAY 401 MODULE CAN BE DAMAGED. Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: CHAMPION BUS IS RECALLING 31 MY 2007-2008 DEFENDER, CHALLENGER AND MY 2008 CRUSADER BUSES BUILT ON GENERAL MOTORS 560 CHASSIS AND EQUIPPED WITH INTERMOTIVE GATEWAY 401 MODULE INTERLOCK HARNESS. THESE BUSES HAVE BEEN FOUND TO EXHIBIT EXTREME VOLTAGE SPIKES DURING ENGINE CRANKING. THESE EXTREME SPIKES CAN DAMAGE THE DIODE IN THE HARNESS NEAR THE SHIFT LOCK SOLENOID CONNECTOR. IF THE DIODE FAILS IN THE SHORTED CONDITION, THE GATEWAY 401 MODULE CAN BE DAMAGED. Recall Details
Problem: CHAMPION BUS IS RECALLING 503 MY 2005-2008 DEFENDER, CHALLENGER, CTS-RE, CTS-FE AND CRUSADER BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA. Recall Details
Problem: CHAMPION BUS IS RECALLING 503 MY 2005-2007 CHALLENGER, CRUSADER, DEFENDER, MY 2005-2006 CORPORAL, MY 2006 CTS-RE, AND MY 2007 CTS-FE AND IC DEFENDER TRANSIT BUSES EQUIPPED WITH A RICON PLATFORM STYLE WHEELCHAIR LIFT. THIS LIFT FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN VEHICLES EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN BUSES EQUIPPED WITH TRANS AIR TA 73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 TRANSIT BUSES MANUFACTURED BETWEEN JANUARY 2003 AND AUGUST 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: CHAMPION BUS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2007-2010 BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 TRANSIT BUSES MANUFACTURED BETWEEN JANUARY 2003 AND AUGUST 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN BUSES EQUIPPED WITH TRANS AIR TA 73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Recall Details
Problem: Champion Bus is recalling certain model year 2006, and certain model year 2008-2013 buses, models: American Crusader, Challenger, Crusader, and Defender; manufactured September 30, 2006, through November 16, 2012. The buses are equipped with a Ricon manufactured wheelchair lift which has an optional armored pendant cable. The cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover. Recall Details
Problem: CHAMPION BUS IS RECALLING 503 MY 2005-2007 CHALLENGER, CRUSADER, DEFENDER, MY 2005-2006 CORPORAL, MY 2006 CTS-RE, AND MY 2007 CTS-FE AND IC DEFENDER TRANSIT BUSES EQUIPPED WITH A RICON PLATFORM STYLE WHEELCHAIR LIFT. THIS LIFT FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT. Recall Details
Problem: ON CERTAIN TRANSIT BUSES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA. Recall Details
Problem: CERTAIN BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, 'PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.' THE INNER BARRIER INTERLOCK SWITCH SYSTEM IN THE LIFT BASEPLATE MAY NOT DETECT THE PRESENCE OF A PASSENGER (EITHER WHEELCHAIR OR STANDEE) ON THE BARRIER AND CAN ALLOW THE PLATFORM TO MOVE DOWN MORE THAN ONE INCH BELOW FLOOR LEVEL WHEN OCCUPIED. Recall Details
Problem: CHAMPION BUS IS RECALLING 503 MY 2005-2008 DEFENDER, CHALLENGER, CTS-RE, CTS-FE AND CRUSADER BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA. Recall Details
Problem: Champion Bus, Inc. (Champion Bus) is recalling certain model year 2006-2014 American Coach, American Crusader, Challenger, Corporal, Crusader, CTS-FE, CTS-RE, Defender, HCAC, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to July 31, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Recall Details
Problem: Champion Bus, Inc. (Champion) is recalling certain model year 2006-2015 Challenger, Defender, Crusader, American, American Coach, American Crusader, Corporal, CTS-FE, CTS-RE, HC American, Platinum Shuttle, and Stacked Rail transit buses manufactured January 1, 2006, to August 25, 2015, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Recall Details
Problem: ON CERTAIN DIESEL BUSES BUILT ON FORD E-SERIES CHASSIS AND EQUIPPED WITH CARRIER VACUUM PUMP BRACKETS, THE BRACKETS COULD BREAK. Recall Details
Problem: ON CERTAIN TRANSIT BUSES EQUIPPED WITH RICON S AND K SERIES PLATFORM STYLE WHEELCHAIR LIFTS, THE VERTICAL SUPPORT ARMS FOR THE LIFTS WERE IMPROPERLY WELDED ALLOWING THE LIFT TO STOW IMPROPERLY. Recall Details
Problem: ON CERTAIN TRANSIT BUSES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA. Recall Details
Problem: CHAMPION BUS IS RECALLING 375 MY 2005-2007 CHAMPION, CHALLENGER, CRUSADER, CTS, DEFENDER AND GENERAL COACH MODEL CORPORAL AND M1235 BUSES EQUIPPED WITH BRAUN PLATFORM LIFTS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." A PASSENGER CAN APPROACH THE EXPOSED LIFT DOORWAY WITHOUT THE AUDIBLE ALARM ALERTING THEM OF THEIR PROXIMITY TO THE THRESHOLD. Recall Details
Problem: CHAMPION BUS IS RECALLING 503 MY 2005-2008 DEFENDER, CHALLENGER, CTS-RE, CTS-FE AND CRUSADER BUSES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2010 TRANSIT BUSES MANUFACTURED BETWEEN JANUARY 2003 AND AUGUST 2009 EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR. Recall Details
Problem: CHAMPION BUS IS RECALLING 503 MY 2005-2007 CHALLENGER, CRUSADER, DEFENDER, MY 2005-2006 CORPORAL, MY 2006 CTS-RE, AND MY 2007 CTS-FE AND IC DEFENDER TRANSIT BUSES EQUIPPED WITH A RICON PLATFORM STYLE WHEELCHAIR LIFT. THIS LIFT FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT. Recall Details
Problem: CHAMPION BUS IS RECALLING CERTAIN BUSES EQUIPPED WITH TRANS AIR TA 73 EVAPORATORS. THE EVAPORATOR UTILIZES A POWER RESISTOR TO REGULATE BLOWER SPEED. SHOULD A SHORT OCCUR IN THE "LOW OR MEDIUM SPEED" CIRCUIT WHILE THE BLOWER IS IN HIGH SPEED, THE SHORT WILL CAUSE THE SUPPLY VOLTAGE TO FEEDBACK THROUGH THE RESISTOR TO GROUND, NOT DRAWING ENOUGH CURRENT TO TRIP THE FUSE. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, A LIGHT GAUGE STEEL WAS USED FOR THE FLOOR FRAME CROSSMEMBER LOCATED IN THE FLOOR SUB-FRAME. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT. Recall Details
Problem: ON CERTAIN DIESEL BUSES BUILT ON FORD E-SERIES CHASSIS AND EQUIPPED WITH CARRIER VACUUM PUMP BRACKETS, THE BRACKETS COULD BREAK. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, A LIGHT GAUGE STEEL WAS USED FOR THE FLOOR FRAME CROSSMEMBER LOCATED IN THE FLOOR SUB-FRAME. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, A LIGHT GAUGE STEEL WAS USED FOR THE FLOOR FRAME CROSSMEMBER LOCATED IN THE FLOOR SUB-FRAME. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, A LIGHT GAUGE STEEL WAS USED FOR THE FLOOR FRAME CROSSMEMBER LOCATED IN THE FLOOR SUB-FRAME. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, A LIGHT GAUGE STEEL WAS USED FOR THE FLOOR FRAME CROSSMEMBER LOCATED IN THE FLOOR SUB-FRAME. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH CP TRAVELING RETRACTOR LAP (TYPE 1) SEAT BELTS, THE PLASTIC COVER HOUSING THE RESERVE END OF THE SEAT BELT WEB CAN BREAK. IF THE TWO HALVES OF THE COVER COMPLETELY SEPARATE, THE CONNECTOR PORTION OF THE BELT WILL DETACH FROM THE COVER. ONCE DETACHED, THE CONNECTOR RIVET CAN SEPARATE FROM THE CONNECTOR FRAME CAUSING THE FRAME TO BECOME UNUSABLE. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH CP TRAVELING RETRACTOR LAP (TYPE 1) SEAT BELTS, THE PLASTIC COVER HOUSING THE RESERVE END OF THE SEAT BELT WEB CAN BREAK. IF THE TWO HALVES OF THE COVER COMPLETELY SEPARATE, THE CONNECTOR PORTION OF THE BELT WILL DETACH FROM THE COVER. ONCE DETACHED, THE CONNECTOR RIVET CAN SEPARATE FROM THE CONNECTOR FRAME CAUSING THE FRAME TO BECOME UNUSABLE. Recall Details
Problem: ON CERTAIN TRANSIT BUSES, A LIGHT GAUGE STEEL WAS USED FOR THE FLOOR FRAME CROSSMEMBER LOCATED IN THE FLOOR SUB-FRAME. Recall Details
Problem: ON CERTAIN BUSES EQUIPPED WITH CP TRAVELING RETRACTOR LAP (TYPE 1) SEAT BELTS, THE PLASTIC COVER HOUSING THE RESERVE END OF THE SEAT BELT WEB CAN BREAK. IF THE TWO HALVES OF THE COVER COMPLETELY SEPARATE, THE CONNECTOR PORTION OF THE BELT WILL DETACH FROM THE COVER. ONCE DETACHED, THE CONNECTOR RIVET CAN SEPARATE FROM THE CONNECTOR FRAME CAUSING THE FRAME TO BECOME UNUSABLE. Recall Details
Problem: CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM WITH SERIAL NUMBERS BETWEEN 700000 AND 1008700 . THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK. Recall Details
Problem: CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM WITH SERIAL NUMBERS BETWEEN 700000 AND 1008700 . THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK. Recall Details
Problem: CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM WITH SERIAL NUMBERS BETWEEN 700000 AND 1008700 . THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK. Recall Details
|