|
Problem: FOUR WINDS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 PRESIDIO, MODEL YEAR 2007-2010 MANDALAY, AND MODEL YEAR 2010 MONTECITO MOTORHOMES BUILT BETWEEN OCTOBER 5, 2004 AND NOVEMBER 25, 2009 ON FREIGHTLINER CHASSIS MANUFACTURED BETWEEN MAY 2007 AND NOVEMBER 2009 WITH KONGSBERG POWER PRODUCTS SYSTEMS ADJUSTABLE BRAKE PEDALS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION. Recall Details
Problem: Thor Motorcoach is recalling certain model year 2008-2010 motorhomes, manufactured June 1, 2007, through May 1, 2009 and equipped with an Iota ITS-50R Transfer Switch. The models affected are Four Winds brand models: Chateau, Dutchmen, Hurricane, Windsport, Magellan, Fun Mover, Presidio, and Mandalay. Wiring connections inside the transfer switch are not adequate and, as a result, the switch may overheat. Recall Details
Problem: Thor Motor Coach (TMC) is recalling certain model year 2009-2011 Four Winds Hurricane and Windsport, 2009-2010 Four Winds Mandalay, 2010 Four Winds Magellan, and 2010-2011 Four Winds Serrano motorhomes manufactured May 2, 2009, to September 1, 2010. The affected vehicles are wired to be powered by a generator and are equipped with an Iota ITS-50R transfer switch that may fail when exposed to elevated electrical loads and used in higher ambient temperatures. Recall Details
Problem: Thor Motor Coach (Thor) is recalling certain model year 2011-2016 Thor Challenger, Thor Citation, Thor Hurricane, Thor Tuscany, Thor Windsport, 2011-2012 Thor Astoria, Thor Avanti, Thor Chateau, 2011-2014 Thor Daybreak, 2011-2015 Thor Outlaw, Thor Siesta, 2014-2015 Thor Miramar, 2012 Thor Four Winds, 2008-2011 Damon Astoria, Damon Daybreak, Damon Outlaw, Damon Tuscany, 2008-2012, Damon Challenger, 2008-2010 Damon Essence, 2009-2011 Damon Avanti, Four Winds Chateau, Four Winds Citation, Four Winds Four Winds, Four Winds Hurricane, Four Winds Siesta, Four Winds Windsport, 2009-2010 Four Winds Dorado, Four Winds Dutchmen, Four Winds Magellan, Four Winds Mandalay and 2009 Four Winds Fun Mover, and Four Winds Presidio motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double and Triple Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable. Recall Details
Problem: Thor Motorcoach is recalling certain model year 2008-2010 motorhomes, manufactured June 1, 2007, through May 1, 2009 and equipped with an Iota ITS-50R Transfer Switch. The models affected are Four Winds brand models: Chateau, Dutchmen, Hurricane, Windsport, Magellan, Fun Mover, Presidio, and Mandalay. Wiring connections inside the transfer switch are not adequate and, as a result, the switch may overheat. Recall Details
Problem: Thor Motor Coach (Thor) is recalling certain model year 2011-2016 Thor Challenger, Thor Citation, Thor Hurricane, Thor Tuscany, Thor Windsport, 2011-2012 Thor Astoria, Thor Avanti, Thor Chateau, 2011-2014 Thor Daybreak, 2011-2015 Thor Outlaw, Thor Siesta, 2014-2015 Thor Miramar, 2012 Thor Four Winds, 2008-2011 Damon Astoria, Damon Daybreak, Damon Outlaw, Damon Tuscany, 2008-2012, Damon Challenger, 2008-2010 Damon Essence, 2009-2011 Damon Avanti, Four Winds Chateau, Four Winds Citation, Four Winds Four Winds, Four Winds Hurricane, Four Winds Siesta, Four Winds Windsport, 2009-2010 Four Winds Dorado, Four Winds Dutchmen, Four Winds Magellan, Four Winds Mandalay and 2009 Four Winds Fun Mover, and Four Winds Presidio motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double and Triple Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable. Recall Details
Problem: Thor Motor Coach (TMC) is recalling certain model year 2009-2011 Four Winds Hurricane and Windsport, 2009-2010 Four Winds Mandalay, 2010 Four Winds Magellan, and 2010-2011 Four Winds Serrano motorhomes manufactured May 2, 2009, to September 1, 2010. The affected vehicles are wired to be powered by a generator and are equipped with an Iota ITS-50R transfer switch that may fail when exposed to elevated electrical loads and used in higher ambient temperatures. Recall Details
Problem: TMC IS RECALLING CERTAIN MODEL YEAR 2004-2011 DAMON AND FOUR WINDS RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT. Recall Details
Problem: FOUR WINDS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 PRESIDIO, MODEL YEAR 2007-2010 MANDALAY, AND MODEL YEAR 2010 MONTECITO MOTORHOMES BUILT BETWEEN OCTOBER 5, 2004 AND NOVEMBER 25, 2009 ON FREIGHTLINER CHASSIS MANUFACTURED BETWEEN MAY 2007 AND NOVEMBER 2009 WITH KONGSBERG POWER PRODUCTS SYSTEMS ADJUSTABLE BRAKE PEDALS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION. Recall Details
Problem: FOUR WINDS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 PRESIDIO, MODEL YEAR 2007-2010 MANDALAY, AND MODEL YEAR 2010 MONTECITO MOTORHOMES BUILT BETWEEN OCTOBER 5, 2004 AND NOVEMBER 25, 2009 ON FREIGHTLINER CHASSIS MANUFACTURED BETWEEN MAY 2007 AND NOVEMBER 2009 WITH KONGSBERG POWER PRODUCTS SYSTEMS ADJUSTABLE BRAKE PEDALS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION. Recall Details
Problem: Thor Motorcoach is recalling certain model year 2008-2010 motorhomes, manufactured June 1, 2007, through May 1, 2009 and equipped with an Iota ITS-50R Transfer Switch. The models affected are Four Winds brand models: Chateau, Dutchmen, Hurricane, Windsport, Magellan, Fun Mover, Presidio, and Mandalay. Wiring connections inside the transfer switch are not adequate and, as a result, the switch may overheat. Recall Details
Problem: TMC IS RECALLING CERTAIN MODEL YEAR 2004-2011 DAMON AND FOUR WINDS RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT. Recall Details
Problem: ON CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING. Recall Details
Problem: ON CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON. Recall Details
Problem: FOUR WINDS IS RECALLING CERTAIN MY 2008-2009 MOTOR HOME CHASSIS EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD. Recall Details
Problem: ON CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING. Recall Details
Problem: FOUR WINDS IS RECALLING 1,633 MY 2004-2007 MANDALAY, MY 2005-2007 PRESIDIO, AND MY 2006-2007 VALENCIA MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT. Recall Details
Problem: CERTAIN MOTOR HOMES MAY HAVE IMPROPER ROUTING OR SUPPORT OF THE PROPANE (LP) GAS LINE TO THE KITCHEN SLIDE-OUT ROOM. Recall Details
Problem: ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE. Recall Details
Problem: FOUR WINDS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 PRESIDIO, MODEL YEAR 2007-2010 MANDALAY, AND MODEL YEAR 2010 MONTECITO MOTORHOMES BUILT BETWEEN OCTOBER 5, 2004 AND NOVEMBER 25, 2009 ON FREIGHTLINER CHASSIS MANUFACTURED BETWEEN MAY 2007 AND NOVEMBER 2009 WITH KONGSBERG POWER PRODUCTS SYSTEMS ADJUSTABLE BRAKE PEDALS. THE DRIVE PIN WHICH SECURES THE BRAKE PEDAL ARM TO THE BALANCE OF THE ASSEMBLY MAY BECOME DISENGAGED, THIS MAY CAUSE A REDUCTION IN VEHICLE BRAKING AND/OR CAUSE THE BRAKE PEDAL TO MOVE OUT OF POSITION AND INTERFERE WITH THROTTLE PEDAL FUNCTION. Recall Details
Problem: TMC IS RECALLING CERTAIN MODEL YEAR 2004-2011 DAMON AND FOUR WINDS RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT. Recall Details
Problem: TMC IS RECALLING CERTAIN MODEL YEAR 2004-2011 DAMON AND FOUR WINDS RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT. Recall Details
Problem: FOUR WINDS IS RECALLING 1,633 MY 2004-2007 MANDALAY, MY 2005-2007 PRESIDIO, AND MY 2006-2007 VALENCIA MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT. Recall Details
Problem: ON CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING. Recall Details
Problem: ON CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING. Recall Details
Problem: CERTAIN MOTOR HOMES DO NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, 'AIR BRAKE SYSTEMS.' IN A SITUATION IN WHICH MULTIPLE ALARMS ARE ACTIVE, A CHECK ENGINE, STOP ENGINE, OR SIMILAR WARNING INDICATOR IS GIVEN PRIORITY OVER THE LOW AIR ALARM BY THE INSTRUMENT SYSTEM CONTROLLER SOFTWARE. IF THE OPERATOR DOES NOT ACKNOWLEDGE THESE HIGHER PRIORITY ALARMS, A LOW AIR ALARM MAY NOT BE DISPLAYED. Recall Details
Problem: ON CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH I-SHAFTS SUPPLIED BY ZF HEAVY DUTY STEERING, THE STEERING SHAFT ASSEMBLIES WITH LOWER YOKES MAY HAVE BEEN INCORRECTLY MACHINED. THE STEERING SHAFT SPLINES COULD PUSH THROUGH THE LOWER YOKE, ALLOWING THE STEERING WHEEL TO TURN WITHOUT ANY RESPONSE. Recall Details
Problem: FOUR WINDS IS RECALLING 1,633 MY 2004-2007 MANDALAY, MY 2005-2007 PRESIDIO, AND MY 2006-2007 VALENCIA MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT. Recall Details
Problem: TMC IS RECALLING CERTAIN MODEL YEAR 2004-2011 DAMON AND FOUR WINDS RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT. Recall Details
Problem: TMC IS RECALLING CERTAIN MODEL YEAR 2004-2011 DAMON AND FOUR WINDS RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT. Recall Details
Problem: CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT. Recall Details
Problem: CERTAIN MOTOR HOMES DO NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, 'AIR BRAKE SYSTEMS.' IN A SITUATION IN WHICH MULTIPLE ALARMS ARE ACTIVE, A CHECK ENGINE, STOP ENGINE, OR SIMILAR WARNING INDICATOR IS GIVEN PRIORITY OVER THE LOW AIR ALARM BY THE INSTRUMENT SYSTEM CONTROLLER SOFTWARE. IF THE OPERATOR DOES NOT ACKNOWLEDGE THESE HIGHER PRIORITY ALARMS, A LOW AIR ALARM MAY NOT BE DISPLAYED. Recall Details
Problem: ON CERTAIN MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING. Recall Details
Problem: FOUR WINDS IS RECALLING 1,633 MY 2004-2007 MANDALAY, MY 2005-2007 PRESIDIO, AND MY 2006-2007 VALENCIA MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT. Recall Details
Problem: CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT. Recall Details
|