THIS RECALL HAS BEEN SUPERCEDED BY RECALL 08E-055. HYUNDAI IS RECALLING 3,387 TRAILER HITCH WIRING HARNESSES

Feb 07, 2008 — Recall Campaign #08E016000

THIS RECALL HAS BEEN SUPERCEDED BY RECALL 08E-055. HYUNDAI IS RECALLING 3,387 TRAILER HITCH WIRING HARNESSES EITHER INCLUDED WITH A TRAILER HITCH OR SOLD AS A SERVICE PART MANUFACTURED BY THULE TOWING SYSTEMS AND DISTRIBUTED BY HYUNDAI FOR INSTALLATION ON MY 2007-2008 SANTA FE AND VERACRUZ VEHICLES. THE ACCESSORY TRAILER HITCH WIRING HARNESS CONVERTER MODULE IS MOUNTED TO THE TOP SURFACE OF THE REAR BUMPER REINFORCEMENT. HIGH CURRENT LEAKAGE OR A SHORT CIRCUIT OF CAPACITOR C1 COULD CAUSE HEAT RELATED DAMAGE TO THE WIRING HARNESS CONVERTER MODULE.

The recall was influenced by the manufacturer with about 3,387 units affected.

See recall notice

NHTSA Safety Recall Notice

08E016000

Manufacturer:	Kia America, Inc.
Recall date:	February 07, 2008
NHTSA Campaign #:	08E016000
Units affected:	3,387

Description:: THIS RECALL HAS BEEN SUPERCEDED BY RECALL 08E-055. HYUNDAI IS RECALLING 3,387 TRAILER HITCH WIRING HARNESSES EITHER INCLUDED WITH A TRAILER HITCH OR SOLD AS A SERVICE PART MANUFACTURED BY THULE TOWING SYSTEMS AND DISTRIBUTED BY HYUNDAI FOR INSTALLATION ON MY 2007-2008 SANTA FE AND VERACRUZ VEHICLES. THE ACCESSORY TRAILER HITCH WIRING HARNESS CONVERTER MODULE IS MOUNTED TO THE TOP SURFACE OF THE REAR BUMPER REINFORCEMENT. HIGH CURRENT LEAKAGE OR A SHORT CIRCUIT OF CAPACITOR C1 COULD CAUSE HEAT RELATED DAMAGE TO THE WIRING HARNESS CONVERTER MODULE.
Consequeces:: EXCESSIVE HEAT MAY CAUSE DAMAGE TO THE REAR BUMPER AREA AND MAY POTENTIALLY RESULT IN A FIRE.
Corrective action:: HYUNDAI WILL NOTIFY OWNERS AND WILL REPLACE THE TRAILER HITCH WIRING HARNESS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 31, 2008. OWNERS MAY CONTACT HYUNDAI AT 1-800-633-5151.
Notes:: HYUNDAI RECALL NUMBER 082.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

HYUNDAI U86102B100 Complaints
THE CAR JUST STARTED SPILLING OUT FUEL AFTER HOURS OF BEING FILLED. WE TOOK THE CAR DIRECTLY TO THE DEALER (WHERE WE PURCHASED IN 2002) AND THEY SAID THAT WE HAD OVER FILLED THE GAS TANK WHICH CAUSED IT TO GO INTO THE CARBON BOX. THIS SEEMS TO BE THE SAME STATEMENT MANY OTHER DRIVERS WERE TOLD FROM DEALERS. $869 DOLLARS LATER, THEY REPLACED THE RECALLED FAULTY TANK CAP (WHICH TO ME WOULD HAVE CAUSED SOME OF THE FUEL TO SWOOSH AROUND WHILE DRIVING - IF NEVER PROPERLY FIT), AND THEN CHARGED US FOR NON-WARRANTY TO REPLACE THE FUEL LINE. AT WHICH TIME, OUR CAR HAS 30,800 MILES AND ORIGINAL OWNERS. UPON PICKING UP THE "FIXED" VEHICLE, THE CHECK ENGINE LIGHT STAYED LIT. WE CALLED THE DEALER BACK IMMEDIATELY, BUT COULD NOT GET IN FOR A WEEK, WE DROVE THE CAR DURING THIS TIME. BROUGHT THE VEHICLE BACK (7/08) AND THEN WAS TOLD THAT THERE WERE THREE "ERROR" READINGS THAT WERE RELATED TO THE FUEL LINE. AFTER SPEAKING TO A COMBATIVE SERVICE TECH, I EXPLAINED THAT THEY DID SOMETHING AND THEY NEEDED TO FIX IT, AS THE ENGINE LIGHT WAS NOT ON PRIOR TO THEIR TECH "FIXING" OUR CAR. SUDDENLY, AFTER I EXPLAINED THAT IF IT IS NOT UNDER WARRANTY THEN THEY ARE NOT CHARGING ME AGAIN FOR SERVICES THAT SHOULD HAVE ALREADY BEEN DONE THE FIRST TIME (UNDER WARRANTY IN MY OPINION). IT WAS AMAZING THAT THE CAR WAS READY TO GO WITH NO OTHER NEEDED SERVICE AND THE "ERROR" LIGHTS WERE NO LONGER DETECTED. HOWEVER, TWO DAYS LATER 7/31/08, OUR CAR WAS TO BE SERVICED AGAIN BECAUSE THE CHECK ENGINE LIGHT IS STILL NOT GOING OFF. NOW, AFTER HAVING AN SMOG CHECK, OUR CAR DID NOT PASS INSPECTION DUE TO:FAILED - EVAPORATIVE EMISSIONS CONTROL SYSTEM DETECTED - GROSS LEAK. EMISSIONS SHOULD BE UNDER WARRANTY AND NOW THE DEALER - PLANET HYUNDAI, LAS VEGAS, IS REFUSING TO ADDRESS THE PROBLEM THAT HAS OCCURRED WHILE THEIR TECH "FIXED" THE FUEL LINE PROBLEM. IT IS MY OPINION THAT AFTER READING SEVERAL OTHER CASES LIKE THIS THAT THE FUEL LINE SPILLAGE IS A COMMON PROBLEM WITH THIS MODEL. *TR;
HYUNDAI U86103J000 Complaints
BRAKE ROTORS FEEL AS IF THERE WARPED WHEN VEHICLE SITS FOR 2 OR 3 DAYS WITHOUT DRIVING. WHEN DRIVEN AFTER THAT TIME PERIOD DESCRIBED ABOVE, WHEN BRAKES ARE PRESS TO STOP VEHICLE, THE VEHICLE GETS A VERY NOTICEABLE PULSATING FEEL IN THE FOOT PETAL. POSSIBLY CAUSING THE VEHICLE NOT TO STOP. A DEFINITE STOPPING CONTROL HAZARD. *TR;
HYUNDAI U86122B000 Complaints
CLUTCH FAILURE! I AM LOOKING AT REPLACING THE CLUTCH IN THIS CAR FOR THE THIRD TIME. AFTER DOING MUCH RESEARCH ON THE ISSUE, I HAVE DISCOVERED THAT THERE ARE SEVERAL CLASS ACTIONS AGAINST HYUNDAI REGARDING THE CLUTCH ISSUE. I HAVE 85K ON THIS CAR AND IT HAS HAD CLUTCH ISSUES SINCE ABOUT 1800 MILES. THE ENTIRE CLUTCH AND FLY WHEEL WAS REPLACED AT 27,618 MILES AND AGAIN AT 60K AND NOW AGAIN. THE PROBLEM IS THE "DUAL MASS FLYWHEEL". THEY KNOW AND ACKNOWLEDGE THIS IS A COMMON PROBLEM WITH THE CLUTCH AND EXPLAIN IT AWAY AS THE WAY THE USER DRIVES. BUT, HOW CAN THOUSANDS DRIVE SO BAD THAT A CLUTCH LAST ONLY 27K MILES? MY HUSBAND DIED 2 WEEKS AFTER THE CAR BROKE DOWN OUT OF TOWN WITH THE 2ND CLUTCH REPLACEMENT. DUE IN PART TO THE ADDED STRESS THAT THIS PUT ON US. HOW MANY OTHER PEOPLE HAVE TO GO THROUGH THIS BEFORE HYUNDAI TAKES THIS SERIOUSLY. HOW MANY PEOPLE HAVE TO INJURED PHYSICALLY, EMOTIONALLY OR FINANCIALLY BEFORE SOMETHING IS DONE. WE WERE ALMOST HIT BY A 18 WHEELER WHEN THE CLUTCH FAILED THE 2ND TIME. AGAIN, HOW MANY PEOPLE DOES HYUNDAI HAVE TO HAVE THIS HAPPEN TO BEFORE SOMEONE IS KILLED!!!!!!! THE DATE LISTED BELOW IS THE 3RD CLUTCH INCIDENT DATE. I HAVE PROOF OF MANY MORE DEFECTS WITH THIS CAR!!!!! I ATTRIBUTE THE DEATH OF MY HUSBAND IN PART TO THIS CONTINUING PROBLEM!!!!! *TR;