BUICK SKYHAWK Recalls

May 19, 2006 – CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

Dec 06, 1988 – A FUEL TANK LEAK COULD OCCUR DUE TO SMALL CREASES ON THE TANK UNDERSIDE CRACKING DURING PRESSURE CYCLING WHICH OCCURS DURING NORMAL OPERATION.

Dec 01, 1987 – THE FUEL FEED AND/OR RETURN HOSE/PIPE ASSEMBLIES COULD CRACK OR SEPARATE, ALLOWING FUEL TO LEAK INTO THE UNDERHOOD AREA.

Oct 26, 1987 – INTERNAL CORROSION OF PULSAIR CHECK VALVE ASSEMBLY COULD PERMIT EXHAUST GAS TO MELT THE PLASTIC SHUT OFF VALVE AND DRAW VALVE PIECES INTO THE AIR CLEANER AND THROTTLE BODY.

May 07, 1987 – THE METAL FLOOR PAN ANCHOR BAR COULD FATIGUE AND BREAK AROUND THE LEFT FRONT OUTER SEAT ADJUSTER STUD OF THE DRIVERS SEAT, ALLOWING THE STUD TO SEPARATE FROM THE FLOOR PAN ANCHOR BAR.

Sep 15, 1986 – PARKING BRAKE LEVER MECHANISMS MAY NOT PROPERLY ENGAGE WHEN APPLIED AS REQUIRED BY FMVSS 105. CONSEQUENCE OF DEFECT: VEHICLE COULD UNEXPECTEDLY ROLL AWAY UNCONTROLLED, WHICH COULD RESULT IN A VEHICLE CRASH.

May 28, 1986 – THE ENGINE AIR CLEANER PLASTIC TRIM COVER COULD FALL OFF THE AIR CLEANER ASSEMBLY AND LAND ON THE EXHAUST MANIFOLD CREATING A FIRE HAZARD. CONSEQUENCE OF DEFECT: IF THE CAR IS BEING OPERATED AT THE TIME THAT THE PLASTIC TRIM COVER FALLS OFF, AN ENGINE COMPARTMENT FIRE COULD OCCUR WITHOUT WARNING.

Nov 18, 1985 – INCORRECT TAIL LAMP LENS WERE INSTALLED, LENS DO NOT CONFORM TO FMVSS 108, LAMP REFLECTIVE DEVICE AND ASSOCIATED EQUIPMENT. CONSEQUENCE OF DEFECT: IN TIMES OF REDUCED VISIBILITY, AN APPROACHING VEHICLE MAY NOT BE AWARE OF THIS VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.

Feb 06, 1984 – SOME VEHICLES HAVE BUCKET SEAT BACK LOCKS THAT DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD 207, ANCHORAGE OF SEATS. IN EVENT OF A CRASH, THE SEAT BACK LOCK MAY NOT FUNCTION.

Oct 13, 1983 – THE BRAKE PROPORTIONER VALVES MAY BREAK AND SEPARATE FROM THE MASTER CYLINDER. THIS WOULD ALLOW BRAKE FLUID TO LEAK AND WOULD RESULT IN A PARTIAL LOSS OF THE BRAKE SYSTEM.