ORION V Recalls

Feb 01, 2005 – ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 50 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO ENTER THE EXHAUST SYSTEM.

Nov 15, 2004 – CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." DURING SUBSEQUENT CLOSING OF AN EMERGENCY EXIT THE MOVING WINDOW FRAME INTERFERES WITH THE JAM FRAME STOP LOCATED IN MID SPAN ALONG THE LOWER EDGE OF THE WINDOW FRAME.

Sep 13, 2004 – ON CERTAIN BUSES, THE BATTERY STORAGE SLIDING TRAY LOCKING TOGGLE WAS NOT TIGHTENED SUFFICIENTLY. THE BATTERY DOOR CAN OPEN ALLOWING THE BATTERY TRAY TO SLIDE OUT FROM THE STORED POSITION.

Aug 30, 2004 – ON CERTAIN BUSES, THE ASSEMBLY OF THE WALKING BEAM CONNECTION TO THE REAR SUSPENSION EXHIBITS LOOSE OR BREAKING OF BOLTS DUE TO MISALIGNED SPACERS.

Aug 19, 2004 – CERTAIN BUSES EQUIPPED WITH COMPRESSED NATURAL GAS FUEL CONTAINERS, MODEL ALT823D, P/N 1273147, DO NOT CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 304, 'COMPRESSED NATURAL GAS FUEL CONTAINER INTEGRITY.' THE NGV CONTAINER'S PRESSURE RELIEF DEVICES FAIL TO TIMELY AND FULLY ACTIVATE AS REQUIRED BY THE STANDARD.

May 20, 2004 – CERTAIN COMPRESSED NATURAL GAS FUEL CONTAINERS, MODEL ALT823D, P/N 1273147, EQUIPPED ON CERTAIN 2003 AND 2004 ORION VII BUSES. THE NVG CONTAINER'S PRESSURE RELIEF DEVICES FAIL TO TIMELY AND FULLY ACTIVATE AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 304, COMPRESSED NATURAL GAS FUEL CONTAINER INTEGRITY.

Mar 23, 2004 – ON CERTAIN BUSES EQUIPPED WITH CUMMINS ELECTRONIC CONTROL MODULES ON THE L10G ENGINES, THE ECM DOES NOT HAVE THE ABILITY TO DETECT A THROTTLE FAIL-SAFE ENGINE SHUTDOWN COMMAND. THIS COULD RESULT IN AN UNANTICIPATED, UNCOMMANDED OPEN THROTTLE CONDITION WITHOUT WARNING.

Mar 27, 2003 – CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THE HANDLE PULL FORCE EXCEEDS THE 89N FORCE TO RELEASE THE EMERGENCY WINDOW. ADDITIONAL FORCE IS REQUIRED TO RELEASE THE WINDOW.

Feb 24, 2003 – ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 50 ENGINE CONFIGURATIONS, A HYDRAULIC MOTOR USED TO DRIVE THE ENGINE COOLING FAN MOTOR HAS TWO HOSES CONNECTED TO IT, INCLUDING A HIGH PRESSURE INPUT HOSE. THE HIGH PRESSURE HOSE IS CONSTRUCTED WITH REUSABLE OR CRIMP ENDS. THE HYDRAULIC MOTOR IS LOCATED AT THE REAR OF THE BUS, INSIDE THE ENGINE COMPARTMENT. THE END OF THE HOSE THAT IS CONNECTED TO THE FAN MOTOR HAS DISCONNECTED FROM THE HOSE CONNECTOR.

Nov 15, 2001 – VEHICLE DESCRIPTION: MEDIUM DUTY TRUCKS, FIRE TRUCKS, AND TRANSIT BUSES AND SCHOOL BUSES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES. THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.