SPARTAN GLADIATOR Recalls

Sep 19, 2002 – ON CERTAIN MOTOR HOMES AND FIRE TRUCKS EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.

Apr 15, 2002 – ON CERTAIN MOTOR HOMES AND FIRE TRUCKS EQUIPPED WITH MERITOR WABCO PNEUMATIC ANITLOCK BRAKE SYSTEM (ABS) VALVE PACKAGES, THE ASSEMBLY BOLTS ON THESE VALVE PACKAGES WERE NOT TIGHTENED CORRECTLY.

May 12, 1999 – VEHICLE DESCRIPTION: FIRE TRUCKS. THESE FIRE TRUCKS ARE ALL 4-DOOR MODELS WHICH CONTAIN DUAL, FORWARD FACING PASSENGER SEATS. THE HARDWARE UTILIZED TO MOUNT THE SEAT BOX TO THE CAB FLOOR AND TO THE BACKWALL STRUCTURE, AND ALSO TO MOUNT THE TYPE 1 SEAT BELT SYSTEMS, WAS INADEQUATE TO MEET THE REQUIREMENTS OF FMVSS NOS. 207/210, ""SEATING SYSTEMS" AND "SEAT BELT ASSEMBLY ANCHORAGES."

Jan 20, 1999 – VEHICLE DESCRIPTION: FIRE TRUCKS. THE CAB TILT SYSTEM CONTAINS A 12 VOLT ELECTRICAL SOLENOID ASSEMBLY AS AN ACCESSORY TO THE CAB TILT ELECTRIC MOTOR/HYDRAULIC PUMP ASSEMBLY. RAIN, SNOW, SALT SPRAY OR OTHER CORROSIVE ENVIRONMENT CAN CORRODE THE SOLENOID OR "BRIDGE" THE ENERGIZING COIL WIRE TERMINAL CAUSING THE CAB TILT SYSTEM TO OPERATE UNCONTROLLABLY.

Nov 06, 1998 – VEHICLE DESCRIPTION: FIRE TRUCKS. IF THE DRIVER ACCELERATES IN A TURN ABOVE 20 MPH FORWARD SPEED, THE LOCK PIN IS ACTUATED AND CAUSES THE AXLE TO RESIST RETURNING TO THE STRAIGHT AHEAD POSITION AFTER THE TURN IS COMPLETED BECAUSE THE LOCK PIN IS BINDING ON THE CLAMP PLATE SURFACE.

Oct 07, 1998 – VEHICLE DESCRIPTION: FIRE TRUCKS. A DEFECTIVE ELECTRICAL HARNESS, PART NO. 200185, WAS USED ON THESE FIRE TRUCKS, CAUSING AN INOPERATIVE 'CHECK TRANSMISSION LIGHT.' THERE WOULD BE NO IN-CAB INDICATION OF A TRANSMISSION FAULT WHICH COULD LEAD TO AN INOPERATIVE VEHICLE IF NOT SERVICED ACCORDING TO THE TRANSMISSION FAILURE CODES.

May 20, 1998 – VEHICLE DESCRIPTION: FIRE TRUCK CHASSIS EQUIPPED WITH TELMA RETARDER AND WABCO VERSION 'D' ANTI-LOCK BRAKE SYSTEM (ABS). THE ABS TEST MODE WIRING WAS INCORRECTLY WIRED THROUGH THE CONSOLE RESULTING IN THE INABILITY TO READ AND CLEAR THE BLINK CODES ON THESE FIRE TRUCKS.

Apr 24, 1998 – VEHICLE DESCRIPTION: FIRE TRUCKS WITH OCCUPANT SIDE ENTRY DOORS. A DIFFICULTY IN LATCHING THE SIDE ENTRY DOORS TO THE FULL CLOSED POSITION, AND/OR, THE DOORS MAY RELEASE TO THE SECONDARY LATCH POSITION. ALSO LOOSE RIVETS CAN CAUSE THE LATCH CONTROL MECHANISM TO BIND NOT ALLOWING THE DOOR TO LATCH PROPERLY WHEN SHUT.

Mar 11, 1996 – THE ELECTRICAL HARNESS POWER DISTRIBUTION CENTER WAS MOUNTED BEHIND THE KICK PANEL IN THE STEP WELL AREA OF THE TRUCK, AND THE UNSEALED CONNECTORS, IF EXPOSED TO WATER, COULD RESULT IN STRAY VOLTAGE, SHORTING, OR CORROSION.

Jul 13, 1995 – AIR SYSTEM BLOCKAGE IN THE AIR DRYER OCCURS DEGRADING THE MOISTURE REMOVING CAPABILITIES OF THE DRYER WHEN THE VEHICLE IS OPERATED IN A COLD ENVIRONMENT AND MOISTURE ACCUMULATES AND FREEZES IN THE AIR DRYER OR IN THE LINE BETWEEN THE DRYER AND THE AIR SYSTEM RESERVOIR. THE AIR DRYER CAN BECOME OVERPRESSURIZED CAUSING THE AIR DRYER CARTRIDGE TO SEPARATE FROM THE MOUNTING BASE.