SPARTAN Recalls

Apr 14, 2011 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2010-2011 FURION, GLADIATOR, AND METROSTAR FIRE APPARATUS CHASSIS/CAB PRODUCED FROM APRIL 8, 2010, THROUGH MARCH 24, 2011. CERTAIN TELL TALES DOES NOT ILLUMINATE WHEN THEY ARE INTENDED (HIGH BEAM LAMP, TURN SIGNALS), OR FLICKER. IN ADDITION, THE ABS LAMP MAY NOT ILLUMINATE WHEN THE SYSTEM IS AFFECTED BY A FAULT. THEREFORE THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, "CONTROLS AND DISPLAYS" AND FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS."

Mar 21, 2011 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008, 2010, AND 2011 GLADIATOR, AS WELL AS MODEL YEAR 2010 METROSTAR VEHICLES MANUFACTURED FROM MARCH 4, 2009 THROUGH FEBRUARY 22, 2011, AND EQUIPPED WITH GUNITE AUTOMATIC SLACK ADJUSTERS. DUE TO AN INCOMPLETE "KNITTING" OF THE IRON AT THE TIME OF CASTING, INADEQUATE STRUCTURAL INTEGRITY OF THE SLACK ADJUSTER HOUSING CAN OCCUR, WHICH COULD CAUSE THE HOUSING TO BREAK AT THE HANDLE UNDER NORMAL OPERATING LOADS.

Jan 11, 2011 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 FURION INCOMPLETE EMERGENCY/RESCUE VEHICLES MANUFACTURED FROM NOVEMBER 5, 2007, THROUGH AUGUST 8, 2009, EQUIPPED WITH CATERPILLAR C7 ENGINES. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.

Aug 12, 2010 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 EMERGENCY RESCUE CHASSIS MANUFACTURED FROM FEBRUARY 3 2009 THROUGH JUNE 3, 2010. THE CONTROL MODULE WHICH HOUSES THE CAB TILT CONTROL CIRCUIT IS SUBJECT TO FLUID INTRUSION. WHEN FLUID ENTERS THE MODULE, AN ELECTRICAL SHORT COULD OCCUR CAUSING THE CAB TO TILT(HOIST) WITHOUT WARNING.

Jun 28, 2010 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 RECREATION VEHICLE CHASSIS MANUFACTURED FROM JUNE 17, 2007 THROUGH MARCH 15, 2010 EQUIPPED WITH TRW IGEN3 INTERMEDIATE STEERING COLUMNS. THE WELD AROUND THE IGEN3 STEERING SHAFT TUBE THAT SECURES THE SPLINE TUBE TO THE INTERMEDIATE TUBE MAY BE MISLOCATED (I.E., NOT FULLY OVER THE SEAM CREATED WHEN THE TUBES ARE PRESSED TOGETHER.)

Jun 07, 2010 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 GLADIATOR AND METROSTAR INCOMPLETE FIRE APPARATUS CHASSIS CABS MANUFACTURED FROM NOVEMBER 14, 2008 THROUGH MAY 25, 2010, EQUIPPED WITH TANDEM REAR AXLES AND ELECTRONIC STABILITY CONTROL (ESC). THE VEHICLES FAIL TO MEET THE SERVICE BRAKE RELEASE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." SPECIFICALLY, ADDITIONAL VALVING REQUIRED FOR THE ESC SYSTEM REDUCED THE AIR FLOW AND VOLUME TO THE BRAKE CHAMBERS RESULTING IN SLOWER SERVICE BRAKE RELEASE TIMING.

May 14, 2010 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 GLADIATOR, METROSTAR, FURION, AND DIAMOND FIRE APPARATUS AND AMBULANCE CHASSIS MANUFACTURED FROM JANUARY 29, 2008 THROUGH JANUARY 25, 2010, EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL SYSTEMS (ESC). IN CERTAIN CASES, THE ESC MAY INADVERTENTLY INTERPRET VEHICLE INSTABILITY, EVEN THOUGH THE VEHICLE MAY BE STABLE, WHICH WOULD REQUIRE INTERVENTION OF BRAKE ACTIVATION TO A SELECTED WHEEL.

May 14, 2010 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 GLADIATOR, METROSTAR, ADVANTAGE, AND DIAMOND FIRE APPARATUS CHASSIS MANUFACTURED FROM JANUARY 1, 2007 THROUGH APRIL 15, 2010, EQUIPPED WITH INDEPENDENT FRONT SUSPENSIONS SUPPLIED BY RIDEWELL CORPORATION. BELL CRANK SUPPORT BRACKETS INSTALLED ON THE SUSPENSION CRADLE MAY CRACK, OR SEPARATE, FROM THE MAIN STRUCTURE (CRADLE ASSEMBLY). CERTAIN WELDS THAT ATTACH THE BELL CRANK SUPPORT BRACKETS MAY HAVE BEEN OMITTED DURING THE WELDMENT OPERATION OF THE SUSPENSION CRADLE.

May 03, 2010 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 GLADIATOR FIRE APPARATUS CLASS 8 VEHICLES MANUFACTURED BEGINNING AUGUST 21, 2007 THROUGH MARCH 8, 2010, EQUIPPED WITH DETROIT DIESEL SERIES 60 ENGINES. THE ENGINE MAY SHUT DOWN UNEXPECTEDLY WHEN A DIESEL PARTICULATE FILTER OVER TEMPERATURE CONDITION IS DETECTED.

Feb 05, 2010 – SPARTAN IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 ADVANTAGE, BARRON, GLADIATOR, METROSTAR, MOUNTAIN STAR, AND TR-1 FIRE APPARATUS CHASSIS CABS MANUFACTURED BETWEEN FEBRUARY 27, 2003 AND NOVEMBER 17, 2009 AND BELTS SOLD TO VARIOUS VEHICLE ALTERS. CERTAIN SEAT BELT ANCHORAGES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."