SPARTAN Recalls

Jun 25, 2018 – Spartan Motors USA (Spartan) is recalling certain 2009-2018 Gladiator and MetroStar emergency vehicles. The fire water pump solenoid may corrode internally, causing a loss of power to the pump control module.

Jun 07, 2018 – Spartan Motors USA (Spartan) is recalling certain 2016-2019 Spartan Specialty Vehicles K2 and K3 motorhome chassis. The tag axle tire may become damaged due to contact with the Diesel Exhaust Fluid (DEF) fill mounting bracket.

May 29, 2018 – Spartan Motors USA (Spartan) is recalling certain 2001-2018 Spartan Gladiator, Diamond, MetroStar, and Advantage emergency response vehicles. The affected vehicles may not be equipped with a pressure protection valve installed between the air reservoir and the lubrication control module. If the air line were to become disconnected between the lubrication control module and the air reservoir, a loss of air to the air brake system could occur. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Mar 29, 2018 – Spartan Motors USA (Spartan) is recalling certain 2004-2007 Spartan Emergency Response Gladiator vehicles equipped with Timoney Independent Front Suspensions. Inconsistent machining may result in fatigue cracks developing over time in the front axle spindles, causing failure of the spindle and the possible separation of a front wheel from the vehicle.

Nov 16, 2017 – Spartan Motors USA (Spartan) is recalling 2014-2017 Spartan Gladiator and MetroStar emergency response vehicles equipped with Hale pressure relief valves in the water pumps used for fire fighting. Rings securing the valves may corrode over time after exposure to water, causing the ring to fail and the pressure relief valve to open, reducing the water pressure available for fire fighting.

Jun 27, 2017 – Spartan Motors USA (Spartan) is recalling certain 2017-2018 K3 and K4 motor home chassis and Gladiator emergency response chassis cabs equipped with Cummins ISX 15L engines. These engines have a fuel pump whose drive gear could possibly slip on its drive shaft, causing a fuel pump function loss, resulting in an engine stall.

May 31, 2017 – Spartan Motors USA (Spartan) is recalling certain 2010-2014 K2 and K3 motor home chassis and Gladiator emergency response chassis cabs. A component within the starter motor may break, potentially resulting in the starter motor overheating or drawing excessive current.

May 01, 2017 – Spartan Motors USA (Spartan) is recalling certain 2008-2017 Gladiator and MetroStar emergency response vehicles equipped with a supplemental park brake system (SPBS). The directions to activate the SPBS incorrectly state to "Pull" the actuation knob, when it should say "Push."

Mar 13, 2017 – Spartan Motors USA (Spartan) is recalling certain 2011-2017 Gladiator, 2016-2017 MetroStar, 2012-2018 K2, 2011-2018 K3, 2017-2018 K4, and 2011-2017 MM vehicles. The ball joints on the independent front suspension (IFS) modules can loosen and separate, leading to a partial loss of steering.

Oct 26, 2016 – Spartan Motors USA (Spartan) is recalling certain model year 2017 Spartan Specialty Vehicle K2 and K3 vehicles manufactured March 24, 2016, to August 31, 2016. The throttle circuit wires on the affected vehicles may not have been be twisted to cancel out electromagnetic interference, and as a result, interference may cause the throttle signal to be higher or lower than intended.