SUZUKI DL1000 Recalls

Jan 19, 2016 – Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2008-2012 AN400, AN400A, DL1000, GSX1300R, 2008-2009 GSF1250S and GSF1250SA, 2008 GSX1300BK and GSX1300BKA, 2008-2010 GSX650F, GSX-R600, GSX-R750, VLR1800, VLR1800T, and 2009-2010 SFV650 and VZ1500 motorcycles. Due to a problem with the circuit board for the regulator/rectifier power module, the motorcycle may not sufficiently charge the battery and the motorcycle may stall.

Dec 18, 2015 – Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 Suzuki DL 1000 motorcycles manufactured January 17, 2014, to June 5, 2014, 2015 Suzuki DL1000 motorcycles manufactured November 4, 2014, to February 6, 2015 and 2016 Suzuki DL1000 motorcycles manufactured June 11, 2015, to July 15, 2015. The affected motorcycles have a wiring harness that may rub against the bottom of the fuel tank. Vibration from riding may cause the wiring insulation to wear off, allowing a bare wire to short circuit against the fuel tank.

Dec 18, 2015 – Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 Suzuki DL1000 motorcycles manufactured January 17, 2014 to June 5, 2014, and 2015 Suzuki DL1000 motorcycles manufactured November 5, 2014, to February 6, 2015. Due to corrosion or being attached to the painted engine case, the battery ground connection may have poor electrical conductivity.

Dec 18, 2015 – Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2014 DL1000 motorcycles manufactured January 17, 2014, to June 5, 2014, and 2015 DL1000 motorcycles manufactured November 5, 2014, to February 6, 2015. The ignition switch terminals of the affected vehicles may corrode if they come into contact with liquid such as salt water. As a result, the motorcycle's electrical power may be disconnected or the switch may be bypassed, preventing the engine from being shut off with the ignition key.

Feb 23, 2011 – SUZUKI IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MOTORCYCLES MANUFACTURED FROM JULY 2007 THROUGH SEPTEMBER 2009, EQUIPPED WITH REGULATOR/RECTIFIER ASSEMBLIES, SUZUKI PART NUMBERS 32800-41F11, 32800-15H10, 32800-05H11, 32800-41G10, 32800-15H00, 32800-18H00, 32800-05G10, 32800-10G10, 32800-05H20, OR 32800-06G01. SOME REGULATOR/RECTIFIER ASSEMBLIES WERE PRODUCED WITH INSUFFICIENT ADHESION BETWEEN THE POWER MODULE (CIRCUIT BOARD) AND THE RECTIFIER CASE THAT CONTAINS A HEAT SINK TO DISSIPATE HEAT. DUE TO INSUFFICIENT ADHESION, HEAT GENERATED ON THE POWER MODULE CIRCUIT BOARD CAN CAUSE THE CIRCUIT BOARD TO DEFORM, AND LIFT OF THE CASE.

Aug 15, 2008 – MOTION PRO IS RECALLING 10,000 AFTERMARKET BRAKE LEVERS, MODEL NO. 14-0415, SOLD FOR USE ON CERTAIN MY 1999 THROUGH 2008 SUZUKI AND MY 1998 THROUGH 2003 YAMAHA MOTORCYCLES. THE LOBE HEIGHT ON SOME OF THESE LEVERS ARE SMALLER AND DO NOT PROPERLY ENGAGE THE STOMP LAMP SWITCH WHICH WILL NOT DEACTIVATE WHEN THE DRIVER RELEASES THE BRAKE LEVER. THE LEVER CAN BE IDENTIFIED BY THE MARKING "JY 378" AT THE BASE OF THE LEVER NEAR THE PIVOT BUSHING.