TOYOTA TACOMA Recalls

Mar 23, 2006 – CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Mar 02, 2006 – ON CERTAIN PICKUP TRUCKS, THE BEAD OF THE TIRE MAY BE DAMAGED DUE TO IMPROPER ASSEMBLY OF THE TIRES ONTO THE WHEELS.

Jun 28, 2005 – ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.

May 17, 2005 – ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.

Feb 11, 2005 – ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.

May 05, 2004 – CERTAIN PICKUP TRUCKS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, 'SEAT BELT ASSEMBLIES.' THE DRIVER'S SIDE SEAT BELT HAS INCORRECT MARKINGS.

May 19, 2003 – ON CERTAIN PICKUP TRUCKS, DURING SIDE IMPACT NCAP TEST (I.E. LINCAP TEST), A FLANGE AT THE REAR END OF THE DOUBLE CAB BODY DEFORMED AND INTERFERED WITH THE FUEL INLET HOSE THAT CONNECTS THE FUEL FILLER PIPE AND FUEL TANK, RESULTING IN DAMAGE TO THE FUEL INLET HOSE.

Aug 01, 2001 – EQUIPMENT DESCRIPTION: THIS RECALL IS FOR TRAILER TOWING WIRE HARNESS CONVERTERS INSTALLED BY DEALERS OR FOR INSTALLATION ON 1999-2000 TOYOTA TUNDRA AND TACOMA VEHICLES. THE CONNECTORS INTEGRATE THE VEHICLE'S TAIL LIGHTS, BRAKE LIGHTS, AND TURN SIGNAL LIGHTS WITH THOSE EQUIPPED ON THE TRAILER, ARE DEFECTIVE. AFFECTED PART NUMBERS ARE: PT207-34000, PT207-34002, PT207-04981, AND PT214-04985. IN THE TUNDRA VEHICLES, THE CIRCUITRY UTILIZED IN THE CONVERTER WAS INADEQUATE TO PROPERLY MANAGE VEHICLE AND/OR TRAILER-SIDE VOLTAGE SPIKES. IF THE CONVERTER IS EXPOSED TO A VOLTAGE SPIKE, IT MAY CAUSE AN ELECTRICAL SHORT OR OPEN CIRCUIT WITHIN THE CONVERTER. IN THE TACOMA VEHICLES, DUE TO DEFICIENT WATERPROOFING AND IMPROPER INSTALLATION LOCATION OF THE CONVERTER, WHICH IS MOUNTED IN THE LOWER PORTION OF THE TAILGATE CAVITY OF THE VEHICLE, AN ELECTRICAL SHORT CIRCUIT WILL OCCUR IF WATER ENTERS THE CONVERTER HOUSING.

Jun 07, 2001 – VEHICLE DESCRIPTION: 4X2 TRUCKS EQUIPPED WITH TU4 WHITE LETTER TIRE UPGRADE OPTION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. TIRE DAMAGE MAY HAVE OCCURRED DUE TO IMPROPER INSTALLATION, WHICH COULD CAUSE THE TIRE TO DEFLATE OR A BULGE APPEARING IN THE SIDEWALL OF THE TIRE.

Aug 06, 1998 – VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STATEMENT REQUIRED IN THE OWNER'S MANUAL THAT "...THE ON-OFF SWITCH SHOULD ONLY BEN USED WHEN A MEMBER OF A PASSENGER RISK GROUP IDENTIFIED IN THE REQUEST FORM IN APPENDIX B......IS OCCUPYING THE RIGHT FRONT PASSENGER SEATING POSITION..." IS MIS-STATED. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS 208, "OCCUPANT CRASH PROTECTION."