TOYOTA Recalls

Jun 28, 2005 – ON CERTAIN REGULAR CAB PICKUP TRUCKS EQUIPPED WITH A BENCH SEAT, THE SEAT POSITION AND SEAT BELT BUCKLE SENSOR CONNECTOR PINS ARE INCORRECTLY POSITIONED DUE TO A WIRE HARNESS MANUFACTURING PROCESS ERROR.

Jun 02, 2005 – CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE A MANUAL AIR BAG ON-OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE A CHILD RESTRAINT LOWER ANCHORAGE SYSTEM IN THE FRONT PASSENGER SEAT. THIS SPECIFICATION DOES NOT MEET THE STANDARD REQUIREMENTS.

May 17, 2005 – ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.

May 16, 2005 – ON CERTAIN PASSENGER VEHICLES, THE STEERING YOKE WAS NOT WELDED TO THE STEERING SHAFT. IF THE VEHICLE IS OPERATED IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY COME OFF FROM THE SHAFT, AND COULD RESULT IN A LOSS OF VEHICLE STEERING CONTROL.

Mar 30, 2005 – CERTAIN PICKUP TRUCKS EQUIPPED WITH BOTH VEHICLE STABILITY CONTROL (VSC) AND THE TRD DUAL EXHAUST SYSTEMS. THE TRD DUAL EXHAUST SYSTEM MET ALL CLEARANCE SPECIFICATIONS ON MODELS WITHOUT VSC, HOWEVER THE DRIVER'S SIDE EXHAUST LOCATED IN A POSITION WHERE CONTACT BETWEEN A BRAKE LINE FOUND ONLY ON VEHICLES WITH VSC AND THE TRD EXHAUST PIPE MIGHT OCCUR.

Feb 11, 2005 – ON CERTAIN PICKUP TRUCKS EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THERE IS A POSSIBILITY THAT THE PARKING BRAKE PEDAL CABLE LOCK NUT MAY NOT HAVE BEEN TIGHTENED TO THE PROPER TORQUE SPECIFICATION. IN THIS CONDITION, THE LOCK NUT MAY LOOSEN AND COME OFF, WHICH WILL REDUCE THE EFFECTIVENESS OF THE PARKING BRAKE.

Dec 15, 2004 – ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A FRONT PASSENGER POWER SEAT, WHEN INSTALLING CERTAIN REAR-FACING INFANT CHILD SEAT BASES ONTO THE SEAT WITH AN EXCESSIVELY HIGH SEATBELT TENSION, IT MAY BE POSSIBLE TO UNSEAT A COMPONENT CALLED THE BUCKLE STATUS SWITCH FROM THE SEAT BELT BUCKLE.

Nov 29, 2004 – CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE LUMINOUS INTENSITY OF THE DAYTIME RUNNING LAMP (DRL) WILL BE MODIFIED TO MEET THE STANDARD REQUIREMENTS.

Nov 22, 2004 – CERTAIN PASSENGER VEHICLES MAY BE EQUIPPED WITH AN IMPROPERLY DESIGNED BRAKE LIGHT SWITCH. A SILICON OXIDE BUILD-UP OCCURS ON THE CONTACTS INSIDE THE BRAKE LIGHT SWITCH, WHICH CAN MAKE IT INOPERABLE.

Sep 17, 2004 – CERTAIN PASSENGER VEHICLES HAVE THE POSSIBILITY THAT THE RECESS RETAINS A RUBBER SEAL RING, WHICH IS LOCATED AT THE END OF THE CYLINDER BODY, AND MAY BE CORRODED DUE TO AN IMPROPER WASHING PROCESS.