VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES

Mar 02, 2000 — Recall Campaign #00V058000

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.

The recall was influenced by the manufacturer with about 213,736 units affected.

See recall notice

NHTSA Safety Recall Notice

00V058000

Manufacturer:	Isuzu Motors Limited
Recall date:	March 02, 2000
NHTSA Campaign #:	00V058000
Units affected:	213,736

Description:: VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. PAINT WAS APPLIED UNEVENLY ON THE REAR AXLES, RESULTING IN INSUFFICIENT PAINT HARDNESS. SHOULD THIS OCCUR ON THE SURFACE THAT CONTACTS THE REAR AXLE LOWER LINK BRACKET BOLT HEAD AND/OR NUT, THE NUT MAY LOOSEN.
Consequeces:: THE BOLT COULD DETACH FULLY, CAUSING SEPARATION OF THE LOWER LINK FROM THE REAR AXLE, INCREASING THE RISK OF LOSS OF VEHICLE CONTROL.
Corrective action:: DEALERS WILL REPLACE THE REAR AXLE LOWER LINK JOINT NUT AND BOLT.
Notes:: OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ISUZU AT 1-800-643-4070, EXT. 343.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

1999 HONDA PASSPORT Complaints
my frame was rusted throughout at 130k miles the car's rear trail arm mount on the frame detached and almost caused me to run into on by traffic numerous times at 25 mph. only once I stopped to pick up my sons from school the car's rear trail arm detached completely from the frame, I had deemed it undrivable and called for someone to come by and tow it back home. on my own further inspection, I noticed an absurd amount of rust in the rear left side, and holes in the frame. as well as I said the rear trail arm detached from the frame.;
1999 ISUZU AMIGO Complaints
TL* THE CONTACT OWNS A 1999 ISUZU AMIGO. WHILE DRIVING, THE CONTACT EXPERIENCED DIFFICULTY CONTROLLING THE VEHICLE. THE CONTACT PULLED OVER, LOOKED UNDER THE VEHICLE, AND NOTICED THE SUSPENSION ON THE REAR DRIVER'S SIDE HAD RUSTED OFF THE VEHICLE. THE CONTACT WAS ABLE TO SAFELY DRIVE THE VEHICLE HOME. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 172,000.;
1999 ISUZU RODEO Complaints
The contact owns a 1999 Isuzu Rodeo. The contact stated that after he started the vehicle, the horn started to sound independently. The contact stated that he had to temporarily remove the fuse for the horn from the steering wheel. No warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the air bag needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 200,000.;