CERTAIN PASSENGER VEHICLES, LIMOUSINES, AND MINI VANS WERE BUILT WITH A NEWLY DESIGNED RESTRAINT CONTROL

Sep 13, 2000 — Recall Campaign #00V270000

CERTAIN PASSENGER VEHICLES, LIMOUSINES, AND MINI VANS WERE BUILT WITH A NEWLY DESIGNED RESTRAINT CONTROL MODULE (RCM). IN SOME CASES, THE RCM DOES NOT RECOGNIZE CERTAIN SYSTEM FAULTS THAT COULD RESULT IN AN AIR BAG OR SEAT BELT PRE-TENSIONER UNEXPECTEDLY ACTIVATING DURING THE SELF-TEST SEQUENCE AT VEHICLE START-UP.

The recall was influenced by the manufacturer with about 18,500 units affected.

See recall notice

NHTSA Safety Recall Notice

00V270000

Manufacturer:	Ford Motor Company
Recall date:	September 13, 2000
NHTSA Campaign #:	00V270000
Units affected:	18,500

Description:: CERTAIN PASSENGER VEHICLES, LIMOUSINES, AND MINI VANS WERE BUILT WITH A NEWLY DESIGNED RESTRAINT CONTROL MODULE (RCM). IN SOME CASES, THE RCM DOES NOT RECOGNIZE CERTAIN SYSTEM FAULTS THAT COULD RESULT IN AN AIR BAG OR SEAT BELT PRE-TENSIONER UNEXPECTEDLY ACTIVATING DURING THE SELF-TEST SEQUENCE AT VEHICLE START-UP.
Consequeces:: THIS CONDITION COULD RESULT IN PERSONAL INJURY.
Corrective action:: DEALERS WILL REPLACE THE RCM IN THESE VEHICLES. OWNER NOTIFICATION BEGAN SEPTEMBER 14, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Notes:: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2001 FORD CROWN VICTORIA Complaints
The vehicle drift back-fourth while driving on highway. Excessive play in steering wheel,;
2001 FORD WINDSTAR Complaints
The contact owns a 2001 Ford Windstar. The contact stated while driving 15 MPH, the rear axle fractured. There was no warning light was illuminated. The vehicle was towed back to the residence. The vehicle had been diagnosed by an independent mechanic. The contact was informed that the failure was due to a stress crack caused by excessive corrosion. The vehicle had not been repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and determined that the VIN was not included in a recall. The failure mileage was approximately 105,000.;
2001 LINCOLN TOWN CAR Complaints
There was a loud pop after I got gas. My car wouldn't stay running. I couldn't figure out what was going on. My husband looked under the hood and the spark plug still attached to the ignition coil had popped out of the engine. All of the screws holding the ignition coils had backed out.;
2001 MERCURY GRAND MARQUIS Complaints
The contact owns a 2001 Mercury Grand Marquis. The contact stated he noticed coolant fluid on the ground underneath the vehicle. The contact started the vehicle and noticed that the high engine temperate warning light was illuminated. The dealer was contacted but was not able to diagnose the vehicle. The manufacturer was contacted and stated that the vehicle was not under recall. The failure mileage was 100,000. The contact stated that the vehicle is at the service dealer awaiting repairs.;