VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON WORKHORSE CHASSIS

Aug 15, 2001 — Recall Campaign #01V257000

VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON WORKHORSE CHASSIS. SPECIFIC FLOOR PLANS AT ISSUE ARE 30D, 30PBD, 32PBD, 36DPD, 36PBD, 36WDD, AND 37WDD. THE SUPPLY AND RETURN LINE CARRYING GASOLINE TO AND FROM THE ENGINE, MAY HAVE BEEN IMPROPERLY ROUTED AND/OR SECURED ON YOUR WORKHORSE GASOLINE CHASSIS.

The recall was influenced by the manufacturer with about 251 units affected.

See recall notice

NHTSA Safety Recall Notice

01V257000

Manufacturer:	MONACO COACH CORPORATION
Recall date:	August 15, 2001
NHTSA Campaign #:	01V257000
Units affected:	251

Description:: VEHICLE DESCRIPTION: MOTOR HOMES BUILT ON WORKHORSE CHASSIS. SPECIFIC FLOOR PLANS AT ISSUE ARE 30D, 30PBD, 32PBD, 36DPD, 36PBD, 36WDD, AND 37WDD. THE SUPPLY AND RETURN LINE CARRYING GASOLINE TO AND FROM THE ENGINE, MAY HAVE BEEN IMPROPERLY ROUTED AND/OR SECURED ON YOUR WORKHORSE GASOLINE CHASSIS.
Consequeces:: AS A RESULT, THE FUEL LINE COULD BECOME DAMAGE, AND INTRODUCE THE RISK OF A FIRE.
Corrective action:: DEALERS WILL INSPECT THE FUEL LINE ROUTING, INSTALL ADDITIONAL MEANS OF SECURING THE FUEL LINE, IF REQUIRED, AND/OR REPLACE THE LINE IF DAMAGE HAS OCCURRED. OWNER NOTIFICATION BEGAN SEPTEMBER 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.
Notes:: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2002 HOLIDAY RAMBLER ADMIRAL Complaints
TL*THE CONTACT OWNS A 2002 HOLIDAY RAMBLER ADMIRAL. WHENEVER THE CONTACT DROVE THE VEHICLE HE NOTICED THAT THE FRONT DRIVER SIDE AND PASSENGER SIDE WINDOWS WERE VERY DIFFICULT TO SEE THROUGH IN ANY WEATHER CONDITIONS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT BOTH WINDOWS NEEDED TO BE REPLACED DUE TO A GAS BUILD UP BETWEEN THE WINDOW PANE. THE CURRENT AND FAILURE MILEAGES WERE 40000.;
2002 HOLIDAY RAMBLER VACATIONER Complaints
BRAKE CALIPERS FAILED TO RETRACT CAUSING THE PADS TO DRAG ON THE ROTORS CAUSING EXTREME HEAT. THE ROTORS GOT SO HOT THE ANTI LOCK SENSOR MELTED CAUSING ANTI LOCK SYSTEM FAILURE INDICATOR LIGHT TO COME ON. THE ROTORS ARE NOTICEABLY OVERHEATED AND VERY SPLOTCHY THEY SHOULD BE POLISHED NOT SPLOTCHY.;
2002 MONACO COACH LAPALMA Complaints
TL* THE CONTACT OWNS A 2002 MONACO COACH LAPALMA RV. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. AS THE BRAKE PEDAL WAS DEPRESSED, THE PEDAL ABNORMALLY TRAVELED TO THE FLOOR BOARD. THE CONTACT STOPPED THE VEHICLE AND AFTER INSPECTING UNDER THE HOOD, NOTICED VAPORS COMING FROM THE MASTER CYLINDER. THE FRONT DRIVER AND PASSENGER SIDE WHEELS SEIZED AND WOULD NOT TURN. THE CONTACT NOTICED SMOKE COMING FROM BOTH FRONT WHEELS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE VEHICLE WAS INCLUDED IN THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 02V278000 (SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS). AFTER THE RECALL REPAIR WAS PERFORMED, THE FAILURE RECURRED. THE MANUFACTURER STATED THAT THEY WOULD COVER THE REPAIR COSTS BECAUSE THE RECALL WAS ALREADY PERFORMED. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE REPAIR. THE TECHNICIAN THEN ADVISED THAT THE MASTER CYLINDER, FRONT BRAKE LINES, AND THE BRAKE FLUID WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT TO NO AVAIL. THE FAILURE WAS NOT CORRECTED. THE APPROXIMATE FAILURE MILEAGE WAS 18,000.;
2002 MONACO COACH MONARCH Complaints
TL*THE CONTACT OWNS A 2002 MONACO MONARCH. WHILE DRIVING 55 MPH, THE CONTACT DETECTED THAT THE BRAKES WERE OVERHEATING. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE CONTACT PULLED OVER AND NOTICED SMOKE COMING FROM THE FRONT PASSENGER SIDE AND REAR WHEELS. THE VEHICLE WAS TOWED. THE BRAKE AND CALIPERS WERE REPLACED EIGHT TIMES. THE CONTACT HAS ALL OF THE REPAIR ORDERS. THE FAILURE MILEAGE WAS 6,200 AND CURRENT MILEAGE WAS 20,865. UPDATED 03-04-08 *BF THE FRONT WHEEL SEAL WAS LEAKING.;