VEHICLE DESCRIPTION: TAURUS/SABLE VEHICLES EQUIPPED WITH 3.0L AND 3.8L ENGINES AND MUSTANG VEHICLES

Dec 21, 2001 — Recall Campaign #01V390000

VEHICLE DESCRIPTION: TAURUS/SABLE VEHICLES EQUIPPED WITH 3.0L AND 3.8L ENGINES AND MUSTANG VEHICLES WITH 3.8L AND 5.0L ENGINES. IT IS POSSIBLE FOR THE ENGINE COOLING FAN BEARING TO SEIZE.

The recall was influenced by the manufacturer with about 695,260 units affected.

See recall notice

NHTSA Safety Recall Notice

01V390000

Manufacturer:	Ford Motor Company
Recall date:	December 21, 2001
NHTSA Campaign #:	01V390000
Units affected:	695,260

Description:: VEHICLE DESCRIPTION: TAURUS/SABLE VEHICLES EQUIPPED WITH 3.0L AND 3.8L ENGINES AND MUSTANG VEHICLES WITH 3.8L AND 5.0L ENGINES. IT IS POSSIBLE FOR THE ENGINE COOLING FAN BEARING TO SEIZE.
Consequeces:: SHOULD THIS OCCUR, EXCESSIVE HEAT COULD BE GENERATED WHICH COULD MELT THE FAN MOTOR ELECTRICAL CONNECTOR. COMPONENTS INSIDE THE COOLING FAN MOTOR COULD IGNITE POTENTIALLY RESULTING IN AN UNDERHOOD FIRE.
Corrective action:: DEALERS WILL INSPECT THE ENGINE COOLING FAN ASSEMBLY AND INSTALL A CIRCUIT BREAKER. IF THE COOLING FAN IS INOPERATIVE, THE FAN AND MOTOR ASSEMBLY WILL BE REPLACED. OWNER NOTIFICATION BEGAN DECEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Notes:: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

1995 FORD MUSTANG Complaints
TL* THE CONTACT OWNS A 1995 FORD MUSTANG. THE CONTACT STATED THAT THE COOLING FAN AND CIRCUIT BREAKER WERE NOT FUNCTIONING PROPERLY. THE DEALER (ONEONTA FORD, 5142 NY-23, ONEONTA, NY 13820, (607) 432-7300) DIAGNOSED THAT THE COOLING FAN ASSEMBLY AND CIRCUIT BREAKER NEEDED TO BE REPLACED, BUT REFUSED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.;
1995 FORD TAURUS Complaints
THIS PAST SUNDAY, ON JUNE 11, 2017 I WAS DRIVING HOME FROM A GRADUATION PARTY AND THERE WAS A LOUD "POW" ONCE I ACCELERATED FROM A STOP. MY STEERING WAS VERY STIFF (AS IF I WAS DRIVING AN ANCIENT LARGE TRUCK WITH NO POWER STEERING, ALSO MY EXHAUST SYSTEM AT LEAST PARTIALLY CAME UNDUN. I WAS ABLE TO GET THE CRIPPLED CAR TO OUR REGULAR REPAIR SHOP, WHO TOLD ME THAT I HAD A SUBFRAME RUST-COLLAPSE. I HAD TALKED TO A SHADETREE MECHANIC FRIEND, WHO SAID THAT IT WASN'T AN ACTUAL SUBFRAME COLLAPSE, BUT THE NEXT LAYER UP, THE ENGINE CRADLE WHOSE SLEEVES ARE NO THICKER STEEL THAN THE UNIBODY SHEETMETAL. ONE OF THE SLEEVES RUSTED THROUGH. SUPPOSEDLY THE ENGINE CRADLE SLEEVES ARE REMOVABLE/OR THE CRADLE ITSELF. MY MECHANIC FRIEND AND THE TOW FELLOW THAT BROUGHT MY CAR BACK TO MY HOME, BOTH SAID THAT WHAT HAPPENED IS QUITE RARE, THEY NEVER HEARD OF SUCH AN INCIDENT. THE CRADLE RUST THROUGH CAUSED MY FRONT SUBFRAME TO PARTIALLY COLLAPSE AND THE ENGINE IS TILTED DOWN ON THE RIGHT-FRONT. THIS DISCONNECTED THE EXHAUST AND BOUND-UP MY RACK-AND-PINION STEERING, RENDERING THE CAR UNSAFE TO DRIVE. THIS CAR IS NOT A RUST-BUCKET, NO RUSTY BODY PANEL HOLES, AND EVERYTHING ELSE STILL WORKS! JUST THE PAINT AND CLEARCOAT ARE FLAKING-OFF. I HAVE LOOKED ON THE INTERNET AND SEARCHED LOCAL SALVAGE YARDS, BUT CANNOT FIND A GOOD ENGINE CRADLE/SLEEVES. YET, THERE ARE SCADS OF GOOD TAURUS ENGINES CHEAPLY AVAILABLE. WHY DIDN'T FORD OFFER REPLACEMENT ENGINE CRADLE/SLEEVES? WAS THERE NO RECALL? I'D BET I'M NOT THE ONLY PERSON THIS HAPPENED TO!! I WOULD LIKE TO GET THIS CAR FIXED! I HAVE PHOTOS OF THE SUBFRAME FALLEN AFTER THE ENGINE CRADLE FAILURE. PLEASE SEND ME AN E-MAIL ADDRESS I CAN UPLOAD THEM TO. I LOSE THIS PAGE IF I TRY TO UPLOAD HERE (4TH TIME!);
1995 MERCURY SABLE Complaints
TL* THE CONTACT OWNS A 1995 MERCURY SABLE. WHILE DRIVING APPROXIMATELY 40 MPH, THE TRANSMISSION JERKED SEVERELY WITH EXTREME HESITATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHO STATED THAT THE REAR SUBFRAME WAS COMPLETELY CORRODED, WHICH CAUSED DAMAGE TO THE TRANSMISSION. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 93V106000 (STRUCTURE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 103,219.;