ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION

May 16, 2002 — Recall Campaign #02V138000

ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.

The recall was influenced by the manufacturer with about 1,550 units affected.

See recall notice

NHTSA Safety Recall Notice

02V138000

Manufacturer:	BMW of North America, LLC
Recall date:	May 16, 2002
NHTSA Campaign #:	02V138000
Units affected:	1,550

Description:: ON CERTAIN PASSENGER VEHICLES, THE ENGINE AUXILIARY/COOLING FAN OPERATION, INCLUDING VARIABLE SPEED, IS ELECTRONICALLY CONTROLLED. FAILURE OF THE FAN MOTOR CAN CAUSE THE ELECTRICAL CIRCUITRY OF THE FAN CONTROL UNIT TO OVERLOAD AND FAIL, CAUSING THE FAN TO STOP OPERATING.
Consequeces:: IF THIS WERE TO OCCUR, ENGINE OVERHEATING AND SUBSEQUENT ENGINE DAMAGE COULD RESULT. IN ADDITION, IT IS POSSIBLE FOR THE FAILURE OF THE ELECTRICAL CIRCUITRY TO CAUSE A FIRE IN THE FAN CONTROL UNIT LOCATED IN THE FRONT OF THE ENGINE COMPARTMENT.
Corrective action:: DEALERS WILL REPLACE THE FAN. OWNER NOTIFICATION BEGAN SEPTEMBER 28, 2001. THIS IS A SUPPLEMENT TO A RECALL THAT BEGAN DURING SEPTEMBER 2001 (SEE RECALL CAMPAIGN 01V206). OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-831-1117.
Notes:: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2001 BMW 325CI Complaints
FAULTY DMTL NOW NEEDS A THIRD COMPONENT AT 49,000. MILES. JUST REPLACED DEFECTIVE WIRING HARNESS IN TRUNK THAT CAUSED SOME LIGHTS TO FAIL AND BURNT UP A RELAY FAULTY DESIGN. TRANSMISSION CABLE GETS STUCK WHEN SHIFTING OUT OF DRIVE & N. NEEDS CABLE RE ALIGNED OR REPLACED FOR THE SECOND TIME IN 49,000. MILES VERY DANGEROUS. DOOR LOCK ACTUATOR HAS FAILED .AGAIN. SOME HAPPEN WHILE DRIVING OTHERS AFFECT PASSENGERS SAFTEY.;
2001 BMW 325I Complaints
Steering wheel angle sensor internal abc-dsc issues, yellow light is on.. Is there a recall for this issue!? Also front door passenger side air bag is not working, I have used OBD reader to confirm all the above...;
2001 BMW 325IT Complaints
BMW CONTACTED ME IN SEPTEMBER ANNOUNCING A SAFETY RECALL OF THE AIRBAGS IN MY VEHICLE, INDICATING THEY REQUIRED REPLACEMENT AND BMW WOULD CONTACT ME TO SCHEDULE THE SERVICE FOR THE RECALL. OVER SIX MONTHS HAVE PASSED WITH NO ACTION BY BMW TO CORRECT THIS URGENT SAFETY DEFECT. THIS IS SIMPLY UNACCEPTABLE. BMW NEEDS TO TAKE ACTION TO CORRECT THIS DEFECT. *TR;
2001 BMW 330CI Complaints
The contact owns a 2001 BMW 330CI. The contact stated while driving approximately 30 MPH at night, the front headlights were flickering on and off. No warning lights were illuminated. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the failure. The manufacturer was made aware of the failure. The approximate failure mileage was 120,000.;
2001 BMW 330I Complaints
-My infrastructure system management has been affected overtime—which covers electronic control units (ECUs), software, and network architecture—are driven by the need to manage increasing system complexity, cybersecurity vulnerabilities, and electronic malfunctions. -My De-icing fluid management system-Has been affected by potential engine damage, reduced structural integrity, and risk of in-flight failure due to overheating. -My vehicle has been affected sense March 3, 2025 - Major Terminal Outage: A massive power outage, traced to a fire and downed power line near the airport, I [XXX] [XXX] believe my Power failures and component-level are faulty… -My vehicles brake lines are not meeting specifications, which could cause leaks & affect the Antilock Brake System (ABS) and Dynamic Stability Control (DSC), increasing the risk of a crash god forbid… I [XXX] [XXX] believe my brake system is faulty. -My Takata driver-side airbag inflators has been affected that can explode upon deployment, spraying metal shrapnel and causing severe injury or death, (Models affected)~2000-2015 series with urgent "Do Not Drive" warnings requiring free, immediate dealer replacement required by (NHSTA)… I [XXX] [XXX] believe my Takata system is faulty. -My water pump system is electrical connector, authorized by NHTSA. Insufficient sealing allows fluid ingress, posing a short circuit and fire risk to prevent hazards… in conclusion, there has been several major BMW safety recall been mandated by the National Highway Traffic Safety Administration. Remedy plan must be completed within 5 days & I would like a copy of reports via email for my lawyer to review my vehicles standards. In conclusion, I need an evaluation appointment & determination assessment asap due to moving after Valentine’s Day to prevent serious safety issues on my journey to Florida. I’m currently 15min from 6312 Aaron Ln Clinton,Md closest & more convenient service center. Thanks for your understanding! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA;