CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE

Aug 09, 2002 — Recall Campaign #02V222000

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

The recall was influenced by the manufacturer with about 133,221 units affected.

See recall notice

NHTSA Safety Recall Notice

02V222000

Manufacturer:	General Motors, LLC
Recall date:	August 09, 2002
NHTSA Campaign #:	02V222000
Units affected:	133,221

Description:: CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequeces:: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Corrective action:: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Notes:: GM RECALL NO. 02032. ALSO, CUSTOMERS CAN CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2003 BUICK LESABRE Complaints
The transmission doesn't shift correctly even after it's warmed up it is erratic and rough while connecting the transmission gears and jerks very hard at most times. The power steering is not working correctly and makes it difficult to drive at all with the combined issues I'm very concerned about my and my family safely;
2003 BUICK RENDEZVOUS Complaints
The gas gage has been off since I bought it in September 2018. I run out of gas right before 1/4 of a tank and when I fill it it goes about 1/4 over the full line. The passenger seat side airbag went off closing the door May 2019.;
2003 CADILLAC DEVILLE Complaints
The contact owns a 2003 Cadillac Deville. The contact stated that the ignition switch seized. Occasionally, the contact was able to wiggle the switch for the ignition to operate. The contact stated that the ignition switch failed to turn or operate as needed. The vehicle was taken to an independent mechanic who was able to replace the ignition switch on three or four occasions. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 105,000.;
2003 CHEVROLET IMPALA Complaints
My car sometimes cuts off while driving. Was on highway 301 running about 60 mph in the middle lane and just lost power no warning. No code no nothing. Sacred me, I truly feel that's a safety issue, for me and the cars behind me. It's bad not knowing when or where this will happen again.;
2003 CHEVROLET MONTE CARLO Complaints
I keep rewriting this because for some reason it keeps timing out everytime I look for the video to attach. I brought the car to taska twice for underhood fire and ignition. No head gasket got fixed no spark plugs there is several issues water keeps getting in tires are rotted electrical problems and now head gasket is messed up because the hood wasn't put on till afterwards for the recall the ignition is still not fixed. Last time I drove it back it stalled out and smelled over heated;