CERTAIN 4X2 SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY

Sep 09, 2002 — Recall Campaign #02V239000

CERTAIN 4X2 SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR 4.2 VEHICLES.

The recall was influenced by the manufacturer with about 80,254 units affected.

See recall notice

NHTSA Safety Recall Notice

02V239000

Manufacturer:	Ford Motor Company
Recall date:	September 09, 2002
NHTSA Campaign #:	02V239000
Units affected:	80,254

Description:: CERTAIN 4X2 SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR 4.2 VEHICLES.
Consequeces:: CUSTOMERS MAY INFLATE THEIR REAR TIRES BASED ON THE INCORRECT TIRE PRESSURE INFORMATION ON THE CERTIFICATION LABEL.
Corrective action:: A SUPPLEMENTARY LABEL WILL BE SENT TO CUSTOMERS TO PLACE NEAR THE CERTIFICATION LABEL TO IDENTIFY THE APPROPRIATE REAR TIRE PRESSURE. THE CUSTOMER MAY ALSO HAVE THE DEALER INSTALL THE LABEL ON THE VEHICLE, IF THEY SO DESIRE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER OR OCTOBER 2002. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Notes:: ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2000 FORD EXPEDITION Complaints
On XXX my 2000 Ford Expedition caught on fire at around 2am. It had not been driven or turned on since XXX, and was sitting parked that whole time. It was parked in the parking lot of my apartment building, right outside of my unit. I was woken up by a loud pop which I believe was the tire exploding, and the flames were tall enough to see outside my second story bedroom window. My entire apartment building was evacuated by the fire department, and some doors were kicked in by them, including mine. After they put the fire out, the fire inspector looked for two hours to determine a cause and were only able to determine that the fire started under the hood, on the drivers side, close to the dashboard area. The vehicle was completely totaled in the fire, and my other car parked next to it was damaged from the fire as well, and the apartment building had a lot of damage from the fire and heat spreading to it. Multiple residents were displaced for a few days at the advice of the fire department, to let units air out from the carcinogenic fumes. The vehicle has been towed and signed over to AutoMoto Salvage yard. I was researching what could have started this fire and found this article where the NHTSA investigated over 600 spontaneous Ford vehicle fires including year 2000 Ford Expeditions, caused by cruise control deactivation switches, which are located in the same place under the hood that the fire department determined my fire originated. [XXX] My vehicle was not listed in any recall, but that article states that over 200 vehicles that caught fire were not either. I'm unsure if the salvage yard still has it available for inspection. It has not been reproduced or confirmed by a dealer. It was inspected by the fire department and police department - insurance did not do their own inspection. There were no warning signs and the vehicle was running like normal. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);
2000 FORD NAVIGATOR Complaints
BLINKERS AND BRAKE LIGHTS STOPPED WORKING ON THE CAR. FUSE #13 WAS BLOWN. WHEN FUSE #13 WAS REPLACED, LARGE QUANTITIES OF WHITE SMOKE BOILED OUT FROM UNDER THE HOOD OF THE CAR. I RAISED THE HOOD AND FOUND THE WIRING TO THE SWITCH INSTALLED ON THE MASTER CYLINDER BURNING. THIS OCCURRED IN MY HOME DRIVEWAY. I PUT THE FIRE OUT. *TR;