ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS

Apr 28, 2003 — Recall Campaign #03V159000

ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.

The recall was influenced by the Office of Defects Investigation with about 1,755,876 units affected.

See recall notice

NHTSA Safety Recall Notice

03V159000

Manufacturer:	General Motors, LLC
Recall date:	April 28, 2003
NHTSA Campaign #:	03V159000
Units affected:	1,755,876

Description:: ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequeces:: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Corrective action:: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Notes:: GM RECALL NO. 03023.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

1996 CHEVROLET BLAZER Complaints
On March 23, 2023 ABS Extended Stopping Distance on snow / slush surface proceeding downhill on a 4 lane highway (7200 South Wasatch Blvd. Midvale Utah). Other vehicles around me were stopping without issue. I noticed my ABS brakes were making the (typical operating sound a type of grinding) and I wasn't stopping. I changed lanes twice to provide for more stopping distance and eventually stopped in the left turn lane within 2 feet from rear-ending other cars had I remained in the inside lane. Located Investigation EA94-038 noting 10,000 complaints, 2000 accidents, 600 injuries. Chevrolet Safety campaign 99I006000 addressing a PCM coding change and replacing the Kelsey Hayes ABS actuator unit. Chevrolet at 800-222-1020 declined to say whether this recall was in force, was a valid recall or had ever existed.;
1996 CHEVROLET SIERRA PU Complaints
RIGHT FRONT PASSENGER'S SEAT BELT SUCKS BACK IN AFTER IT'S LOCKED IN BUCKLE. KEEPS TIGHTENING IF A BUMP IS HIT OR A PERSON MOVES. TOOK TO DEALER & WAS INFORMED IT'S FOR A CHILD RESTRAINT. CAN PULL OUT BELT, BUT IT KEEPS TIGHTENING. HAS CONTACTED THE MANUFACTURER. *AK *ML;
1996 CHEVROLET TAHOE Complaints
TL* THE CONTACT OWNS A 1996 CHEVROLET TAHOE EQUIP WITH DEXTEERO DHT2 TIRES, SIZED: P265/75R/16, DOT 01BTHBAC00420, AND LINE: NOT AVAILABLE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A LEFT TURN THE FRONT DRIVERS SIDE TIRE SUDDENLY EXPERIENCED A BLOW OUT CAUSING THE DRIVER TO LOOSE CONTROL OF THE STEERING AND CRASHED INTO A GUARD RAIL. NO INJURIES WERE REPORTED. NO POLICE REPORT WAS TAKEN AND THE VEHICLE WAS TOWED AWAY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER WALMART LOCATED AT 10404 6TH ST RANCH CUCAMONGA CA. NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE SAME FAILURE MILEAGE WAS APPROXIMATELY 100 FOR THE TIRE. *LN* *BF *TR;
1996 GMC JIMMY Complaints
TL* THE CONTACT OWNS A 1996 GMC JIMMY. THE CONTACT STATED THAT THE REAR BRAKES FAILED AND THE ABS WARNING LIGHT WAS CONTINUOUSLY ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE REAR CYLINDERS NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOWEVER, THE REMEDY FAILED TO REPAIR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. THE VIN WAS NOT AVAILABLE.;
1996 GMC YUKON Complaints
THE CABLE RELEASE FOR THE REAR SEATS FREEZE UP AND THE CABLES BREAK. THIS COULD TRAP SOMEONE IN THE BACK IF RIDING IN REAR, OR 3RD ROW SEATS. IF THE CAR CATCHES ON FIRE AND A PERSON WHO CAN'T CLIMB FORWARD OVER THE SEATS, IT WOULD BE DEVASTATING ON WHAT COULD HAPPEN. I FEEL AS THIS SHOULD BE A RECALL ON GENERAL MOTORS. MINE BROKE AND I AM UNABLE TO FOLD MY SEATS FORWARD. THIS IS A BAD DESIGN AND THE CABLES RUST AND SNAP WHEN BOTTOM OF SEAT IS FOLDED FORWARD, WHICH IS SUPPOSED TO RELEASE THIS WAY.;