ON CERTAIN PASSENGER VEHICLES, THE ENGINE OIL FILTER DRAIN PLUG MAY BE INSUFFICIENTLY TIGHTENED

Aug 26, 2003 — Recall Campaign #03V324000

ON CERTAIN PASSENGER VEHICLES, THE ENGINE OIL FILTER DRAIN PLUG MAY BE INSUFFICIENTLY TIGHTENED. THIS COULD LEAD TO LOOSENING OF THE PLUG CAUSING AN INITIAL OIL SPRAY AND A SUBSEQUENT OIL LEAK.

The recall was influenced by the manufacturer with about 2,400 units affected.

See recall notice

NHTSA Safety Recall Notice

03V324000

Manufacturer:	BMW of North America, LLC
Recall date:	August 26, 2003
NHTSA Campaign #:	03V324000
Units affected:	2,400

Description:: ON CERTAIN PASSENGER VEHICLES, THE ENGINE OIL FILTER DRAIN PLUG MAY BE INSUFFICIENTLY TIGHTENED. THIS COULD LEAD TO LOOSENING OF THE PLUG CAUSING AN INITIAL OIL SPRAY AND A SUBSEQUENT OIL LEAK.
Consequeces:: IF A LARGE AMOUNT OF OIL LOSS OCCURS, ENGINE DAMAGE MAY RESULT. DEPENDING ON THE EXTENT OF THE DAMAGE, A CRASH COULD OCCUR.
Corrective action:: DEALERS WILL INSPECT THE TORQUE OF THE OIL FILTER DRAIN PLUG AND, IF NECESSARY, RETIGHTEN THE DRAIN PLUG WITH THE CORRECTLY SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON SEPTEMBER 12, 2003. OWNERS SHOULD CONTACT BMW AT 1-800-831-1117.
Notes:: CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2003 BMW 745I Complaints
The contact owns a 2003 BMW 745i. The contact stated while pulling into the garage and depressing the brake pedal, the engine revved up loudly. The contact stated that upon releasing the brake pedal, the vehicle accelerated unintendedly, crashed into a refrigerator and pushed the refrigerator into the wall. The air bags did not deploy. There was no injury sustained. There was no police report filed. The contact parked and turned off the vehicle. The contact stated that the failure reoccurred the following day. The contact stated that the ABS warning light and the brake warning light had illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the failure was related to NHTSA Campaign Number: 10V446000 (Service Brakes, Hydraulic), and the contact was referred to the dealer. The vehicle was not repaired. The dealer was not contacted. The manufacturer was notified of the failure and informed the contact that the vehicle could not be repaired under the recall because the VIN was not included. The failure mileage was approximately 47,000.;
2003 BMW 745LI Complaints
The contact owns a 2003 BMW 745LI. The contact stated while driving approximately 70 MPH, the brake fluid warning light illuminated. The vehicle was taken to the local dealer and diagnosed with rotors, brake wear sensors, and brake failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 174,500.;
2003 BMW 760LI Complaints
THE HIGH PRESSURE FUEL PUMPS FAIL WHICH CAUSE THE CAR TO STALL AND CUT OFF WHILE DRIVING. IF YOU TURN THE CAR OFF AND ION IT MAY START BACK UP AND RUN AGAIN, BUT IT WILL CONTINUE TO STALL AND CUT OFF. BMW KNOWS THIS IS A KNOWN ISSUE AND SAYS BOT HIGH PRESSURE FUEL PUMPS NEED TO BE REPLACED AT $2700 A PIECE. MY VEHICLE HAS 90,000 MILES ON IT.;