CERTAIN SPORT UTILITY AND PASSENGER VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD

Feb 11, 2004 — Recall Campaign #04V067000

CERTAIN SPORT UTILITY AND PASSENGER VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER'S MANUAL DOES NOT CONTAIN A STEP-BY-STEP DESCRIPTION FOR HEADREST ADJUSTMENT WHEN INSTALLING A CHILD RESTRAINT SYSTEM (CRS) TETHER STRAP.

The recall was influenced by the manufacturer with about 134,000 units affected.

See recall notice

NHTSA Safety Recall Notice

04V067000

Manufacturer:	Mitsubishi Motors North America, Inc.
Recall date:	February 11, 2004
NHTSA Campaign #:	04V067000
Units affected:	134,000

Description:: CERTAIN SPORT UTILITY AND PASSENGER VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE OWNER'S MANUAL DOES NOT CONTAIN A STEP-BY-STEP DESCRIPTION FOR HEADREST ADJUSTMENT WHEN INSTALLING A CHILD RESTRAINT SYSTEM (CRS) TETHER STRAP.
Consequeces:: IF THE TETHER STRAP IS IMPROPERLY INSTALLED TO THE TETHER ANCHOR, THE CHILD SAFETY SEAT MAY NOT BE SUFFICIENT RESTRAINED. IN THE EVENT OF A CRASH, THE CHILD COULD BE INJURED.
Corrective action:: A LETTER OUTLINING THE PROBLEM WILL BE SENT TO OWNERS ALONG WITH A STICKER CONTAINING THE CORRECT INSTRUCTIONS AS WELL AS INSTRUCTIONS ON WHERE TO AFFIX THE STICKER IN THE OWNER'S MANUAL. THE RECALL BEGAN ON MARCH 29, 2004. OWNERS SHOULD CONTACT MITSUBISHI AT 1-888-648-7820.
Notes:: MITSUBISHI RECALL NO. SR-04-002.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2001 MITSUBISHI MONTERO SPORT Complaints
On multiple occasions, the horn itself will start blowing without command. After pressing the horn to alert another driver, the horn will then stick again. There are repairs where 3m tape is applied to the horn switch behind the airbag, however it is not a professional repair and looks like it could potentially cause the horn to blow without command again.;
2003 MITSUBISHI DIAMANTE Complaints
TL* THE CONTACT OWNS A 2003 MITSUBISHI DIAMANTE EQUIPPED WITH COOPER CS3 TIRES (NA). WHILE DRIVING 25 MPH, AIR FROM THE VEHICLE'S FRONT DRIVER SIDE TIRE BEGAN TO BE RELEASED. THE CONTACT PULLED THE VEHICLE INTO A FUEL STATION/REPAIR SHOP WHERE THE TIRE WAS REPLACED. THE CONTACT TOOK THE VEHICLE TO THE INDEPENDENT MECHANIC THAT SOLD HIM THE TIRES. THE TIRES WERE MEASURED AND THE CONTACT WAS INFORMED THAT EACH OF THEM NEEDED TO BE REPLACED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRE SIZE WAS UNKNOWN. THE APPROXIMATE TIRE FAILURE MILEAGE WAS 198,000 AND THE VEHICLE FAILURE MILEAGE WAS 216,242.;
2003 MITSUBISHI OUTLANDER Complaints
The contact owns a 2003 Mitsubishi Outlander. The contact stated while driving at approximately 25 MPH, the vehicle came to an immediate stop and did not return to normal operation. The contact noticed that the front control arm had detached. No warning light was illuminated. The contact researched and became aware of NHTSA Campaign Number: 16V458000 (Suspension). The vehicle was not drivable and was towed to the residence. A dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that the VIN was included in the recall but already had been serviced under the recall; however, the failure occurred. The failure mileage was 188,000.;