ON CERTAIN PASSENGER VEHICLES WITH MANUAL TRANSMISSIONS, THE HEAT INSULATOR MAY BE CRACKED CAUSING ABNORMAL

Feb 17, 2004 — Recall Campaign #04V075000

ON CERTAIN PASSENGER VEHICLES WITH MANUAL TRANSMISSIONS, THE HEAT INSULATOR MAY BE CRACKED CAUSING ABNORMAL NOISE.

The recall was influenced by the manufacturer with about 12,000 units affected.

NHTSA Safety Recall Notice

04V075000

Description:: ON CERTAIN PASSENGER VEHICLES WITH MANUAL TRANSMISSIONS, THE HEAT INSULATOR MAY BE CRACKED CAUSING ABNORMAL NOISE.
Consequeces:: CONTINUED OPERATION OF THE VEHICLE CAN CAUSE THE INSULATOR TO COME OFF AND COULD POSE A HAZARD TO FOLLOWING VEHICLES.
Corrective action:: DEALERS WILL REPLACE THE HEAT INSULATOR. THE RECALL BEGAN MARCH 5, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
Notes:: MAZDA RECALL NO. 1704B.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

2004 MAZDA RX-8 Complaints
No worries — here it is trimmed to under 2,000 characters: I am reporting a recurring safety defect on my 2004 Mazda RX-8 (VIN: [XXX] a repair under NHTSA Recall 1017E (Fuel Pump Ring / Discharge Pipe). Recall 1017E was completed on my vehicle on September 19, 2017. The same fuel leak has since recurred, with fuel vapor now entering the passenger cabin. Only a few thousand miles have been driven since the recall repair. The vehicle is currently at Della Mazda, Queensbury, NY at approximately 72,000 miles. On May 8, 2026, I contacted Mazda Customer Experience Center. Mazda confirmed the dealer submitted a pre-authorization request for recall coverage, which Mazda corporate denied, stating the recall was previously completed and further repairs are my responsibility. I have a chat transcript documenting this. A recall remedy that fails to correct the covered defect should not be considered complete. I am requesting NHTSA review whether Recall 1017E has produced recurring failures, direct Mazda to honor the recall remedy, and advise on available consumer reimbursement. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);