CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD

Nov 01, 2004 — Recall Campaign #04V528000

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.

The recall was influenced by the manufacturer with about 92,863 units affected.

See recall notice

NHTSA Safety Recall Notice

04V528000

Manufacturer:	General Motors, LLC
Recall date:	November 01, 2004
NHTSA Campaign #:	04V528000
Units affected:	92,863

Description:: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.
Consequeces:: FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH.
Corrective action:: DEALERS WILL INSPECT THE ACCELERATOR PEDAL ARM AND REPLACE THE ACCELERATOR AND BRAKE PEDAL ASSEMBLY WITH A NEW ASSEMBLY, IF NECESSARY. THE RECALL BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Notes:: GMRECALL NO. 04092. CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-327-4236.

Affects the following:

2003 CHEVROLET MALIBU Complaints
The contact owns a 2003 Chevrolet Malibu. The contact discovered that while driving at various speeds, the key could be removed from the ignition while the engine was still running. The contact later received notification of NHTSA Campaign Number: 14V400000 (ELECTRICAL SYSTEM). The vehicle was taken to the dealer for service, and the vehicle was returned in less than 30 minutes. The contact was suspicious about the work that was performed on the vehicle. The contact stated that soon after the recall repair, the key remained stuck in accessory mode while attempting to turn off the vehicle. Due to the failure, the contact was forced to remove the key from the ignition while the engine was running and used pliers to unhook the battery to turn off the vehicle. Additionally, while driving 20 MPH over a bump in the road, the key was knocked out of the ignition, causing the vehicle to abruptly shut off. The contact lost control of the vehicle, and the vehicle veered off into the grass before coming to a complete stop. Despite the failure, the contact was able to restart the vehicle and drove to the residence and parked the vehicle. The contact alerted the dealer of the failure and that the recall was not properly serviced. The contact was given an estimate for a diagnostic test, and the contact refused to pay for the diagnostic test. The manufacturer was notified of the failure, and the contact was informed that a representative would give a follow-up call. The vehicle was not repaired. The failure mileage was approximately 220,000.;
2003 OLDSMOBILE ALERO Complaints
The contact owned a 2003 Oldsmobile Alero. The contact stated while driving approximately 5 MPH and crossing an intersection, a speeding police vehicle crashed into the driver's side of the vehicle and the front driver's side wheel was bent. The air bags failed to deploy and the contact hit her chest against the steering wheel. Additionally, the left side of the contact' body hit the driver's side window. The contact was knocked unconscious for approximately 30 minutes. The police officers removed the driver's side door and assisted the contact out of the vehicle. The emergency units transported the contact to the hospital, where she spent one night. The contact was then transported to another hospital where she spent two weeks. The contact sustained severe head, collarbone, neck, and back pain. Additionally, the contact sustained chest pain bruises, and a broken left foot. The contact was then sent to a rehabilitation center where she spent one week. The contact was then transported to her residence by emergency units. The contact stated that she had not been able to work properly and she had been depressed. The vehicle was towed to a tow lot, where it was totaled. A police report was filed. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 75,000.;
2003 PONTIAC GRAND AM Complaints
Engine has lost power from 150hp @ 3K RPM and 200ft·lb @ 4K RPM. It is now 50hp @ ½K RPM & 75ft·lb @ 2K revolutions per minute. Gear Shift Button has seperated from globe. Radio needs to be replaced or reset daily. Rear window defroster has seperated from window, and won’t retain position. Tire Pressure Monitoring System hasn’t worked to no avail. Turn signals are showing discrepancies when activated from switch.;