ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER

Dec 15, 2004 — Recall Campaign #04V586000

ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.

The recall was influenced by the manufacturer with about 19,284 units affected.

See recall notice

NHTSA Safety Recall Notice

04V586000

Manufacturer:	Volkswagen Group of America, Inc.
Recall date:	December 15, 2004
NHTSA Campaign #:	04V586000
Units affected:	19,284

Description:: ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequeces:: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Corrective action:: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Notes:: VW RECALL NO. VY.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2005 VOLKSWAGEN BEETLE Complaints
The contact's son owned a 2005 Volkswagen Beetle Turbocharged. The contact stated that while her son was driving at 60 MPH during early evening hours, he traveled over black ice in the road, which caused the vehicle to spin around several times before crashing into the guardrail and concrete wall several times, striking the front and rear of the vehicle, where it eventually came to a stop. The air bags did not deploy. There was no reported fire. The front passenger side occupant sustained a severe concussion. The driver sustained a spinal curvature injury and a severe concussion. Medical attention was received, and both occupants were seen at a hospital. There were no warning lights illuminated before or after the failure. The police were on the scene, but it was unknown if a police report was filed. The contact stated that the failure was related to NHTSA Campaign Number: 08V178000 (Air Bags). The contact spoke with the sheriff, who referred to a lawyer. The vehicle was towed to a tow lot. The contact was notified of the crash through the 360 app. A local dealer was able to be located. The vehicle was not diagnosed or repaired. The vehicle was deemed a total loss by the insurance company. The failure mileage was approximately 220,000. The VIN was not available.;
2005 VOLKSWAGEN GOLF Complaints
Brake Booster Vacuum Line Fell off making me run a red light I could not stop the car in time. After getting the car stopped about 100 feet past the light I found that the Brake Booster Vacuum Line fell off its made of hard plastic that has become brittle it cracked at both ends. There was no warning lights even after it fell off. The part number of the hose is 130-612-041 I just wanted to let someone know before people start getting hurt...;
2005 VOLKSWAGEN JETTA Complaints
The drivers seat moves by it's self while driving. And apparently while it is parked which runs the battery dead;
2005 VOLKSWAGEN PASSAT Complaints
Electronic control module, electronic body module starts going out, it will not let you open the doors from the outside without rolling the windows down and sometimes won't even let you open them with the inside door handles. This is a major safety issue in a wreck or fire especially if you cannot get out of the car. Sometimes they work and sometimes they don't. For a vehicle that everyone complains about with this, and as expensive as it is to fix, are you going to wait until someone dies to make them fix it? When people complain if someone would just Google these issues you would find out just because not everyone knows about NHTSA, that these are extremely common issues that need to be fixed by Volkswagon!;