CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD

Feb 09, 2005 — Recall Campaign #05V046000

CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN THREE SECONDS, AS REQUIRED.

The recall was influenced by the manufacturer with about 19,924 units affected.

See recall notice

NHTSA Safety Recall Notice

05V046000

Manufacturer:	General Motors, LLC
Recall date:	February 09, 2005
NHTSA Campaign #:	05V046000
Units affected:	19,924

Description:: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IF ONE OF THE TWO ACCELERATOR PEDAL RETURN SPRINGS FAILS AND THE TEMPERATURE IS -22 DEGREES F TO -40 DEGREES F, THE ENGINE MAY NOT RETURN TO IDLE WITHIN THREE SECONDS, AS REQUIRED.
Consequeces:: IF THIS WERE TO OCCUR, GREATER BRAKE PEDAL FORCE AND A LONGER DISTANCE MAY BE REQUIRED TO STOP THE VEHICLE.
Corrective action:: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY. THIS RECALL BEGAN ON MARCH 8, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339 OR PONTIAC AT 1-800-620-7668.
Notes:: GM RECALL NO. 05018.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2004 CADILLAC SRX Complaints
The contact owns a 2004 Cadillac SRX. The contact stated that while driving approximately 65 MPH, the vehicle stalled, and the power steering and power brakes were inoperative. No warning lights were illuminated. The failure had occurred on several occasions. The contact researched and became aware of an unknown recall related to the failure; however, the VIN was not under recall. The vehicle was taken back to the residence, and a dealer was contacted. The contact was informed that the electronic stability control module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.;
2004 CADILLAC XLR Complaints
The contact owns a 2004 Cadillac XLR. The contact stated that while driving approximately 70 MPH, there was an abnormal sound like a shotgun being fired overhead. The contact pulled over and observed that the retractable fiberglass roof panel had detached from the frame of the vehicle. The contact stated that the headliner, cables, and pulleys used to retract the roof were exposed. The contact was unable to recover the panel. The contact called the dealer and the manufacturer and was informed that there were no recalls on the VIN for the failure. The contact was informed that the roof panel could be replaced out-of-pocket. The vehicle was not repaired. The failure mileage was approximately 88,000.;
2004 PONTIAC GRAND PRIX Complaints
The contact owned a 2004 Pontiac Grand Prix. The contact stated that the "Low Oil" message was displayed monthly, requiring oil to be added to the engine. While driving at approximately 5 MPH, the contact noticed smoke in the cabin near the floor on the passenger’s and driver’s sides, extending towards the dashboard. After stopping and exiting the vehicle, the contact noticed fire underneath the driver's side door, near the rear of the tire extending up towards the dashboard. The contact stated that the fire quickly spread from the engine to the cabin of the vehicle. The Fire Department was called and responded; however, it took a considerable amount of time to extinguish the fire in the engine compartment. The vehicle was subsequently towed from the scene and declared a total loss. A Fire report and Police report were filed. The contact linked teh failure to NHTSA Campaign Number: 15V201000 (Engine and Engine Cooling). The contact had not sustained any injuries. Neither the dealer nor the manufacturer were notified of the failure. The failure mileage was 200,000.;