ON CERTAIN PASSENGER VEHICLES, A LOOSE TERMINAL IN THE MAIN FUSE BOX MAY CAUSE THE FUEL PUMP TO LOSE

Apr 05, 2005 — Recall Campaign #05V132000

ON CERTAIN PASSENGER VEHICLES, A LOOSE TERMINAL IN THE MAIN FUSE BOX MAY CAUSE THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.

The recall was influenced by the manufacturer with about 1,923 units affected.

See recall notice

NHTSA Safety Recall Notice

05V132000

Manufacturer:	Honda (American Honda Motor Co.)
Recall date:	April 05, 2005
NHTSA Campaign #:	05V132000
Units affected:	1,923

Description:: ON CERTAIN PASSENGER VEHICLES, A LOOSE TERMINAL IN THE MAIN FUSE BOX MAY CAUSE THE FUEL PUMP TO LOSE POWER. IF THE FUEL PUMP BECOMES INOPERATIVE, THE ENGINE MAY NOT START.
Consequeces:: IF THE FUEL PUMP LOSES POWER WHILE DRIVING THE ENGINE COULD STALL WITHOUT WARNING WHICH COULD RESULT IN A CRASH.
Corrective action:: DEALERS WILL REPLACE THE ENTIRE FUSE BOX FREE OF CHARGE. THE RECALL BEGAN ON APRIL 13, 2005. OWNERS MAY CONTACT HONDA AT 800-999-1009 OR ACURA AT 1-800-382-2238.
Notes:: HONDA RECALL NOS. P73, P74.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2005 ACURA TL Complaints
The vehicle has been gradually leaking power steering fluid over time. I have been monitoring the fluid level and have noticed a recurring burning smell while operating the vehicle. At times, I have also observed what appears to be a very faint, clear or nearly transparent smoke or vapor that is only visible when light reflects off of it. I am uncertain whether this is smoke or vapor. The steering has not become difficult or hard to turn at this time. I am concerned that power steering fluid may be leaking onto or near a hot engine or exhaust component, causing the burning smell and possible smoke or vapor and creating a potential fire or safety hazard. The exact source and cause of the leak are currently UNKNOWN. The vehicle and affected components are available for inspection upon request.;
2005 HONDA ACCORD Complaints
Front air bag indicator light stays on while driving. Was replaced twice. And the problem is still going on. It's been four years since it's been replaced.;
2005 HONDA ODYSSEY Complaints
I bought the 2005 Odyssey van in 12/2015. It now has 192,426 miles on it. Three or four times every year since I bought it, the engine will suddenly surge when coming to a stop sign or light, with my right foot on the brake pedal, braking and slowing the van for the stop sign or light. The engine revs to about 5000 or 6000 RPMs. It is as if the engine is flooring the gas pedal. Every time, I have been able to push the brake pedal down hard, even though the car continues to slowly roll forward, and shove it into neutral. I have to then tap the gas pedal to stop the engine accelerating. It then goes back to idling normally. Note, it even happened to me one time when I put it into reverse while parking! So very scary each and every time it happens. On [XXX], I took the van to Don Jacobs Honda Dealership, Lexington, KY. They said there were no reports of this ever happening to anyone else. They charged me $3216.06, with most of the cost for a new timing belt/water pump and a valve adjustment. When their repairs did not solve the problem, I called them. They said they would like to put a monitor on the van and drive it until the surge happened again. I told them to let me drive the van with the monitor, as the next surge might not happen for several months, and I needed to drive the van on a daily basis for work. They said they weren't allowed to let customers use the monitor! I finally had time today to research the surging problem. I noticed on [XXX] that this problem with Honda has never been figured out or fixed! And it keeps happening on even newer Honda Odysseys! I now have the resources to quit driving this van. I would be willing to donate the van to the NHTSA so that they may research and try to figure out how to stop this defect! No telling how many people have been injured or killed due to this defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);