ON CERTAIN SEDANS AND WAGONS, THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED

Jun 02, 2005 — Recall Campaign #05V245000

ON CERTAIN SEDANS AND WAGONS, THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.

The recall was influenced by the Office of Defects Investigation with about 291,652 units affected.

See recall notice

NHTSA Safety Recall Notice

05V245000

Manufacturer:	General Motors, LLC
Recall date:	June 02, 2005
NHTSA Campaign #:	05V245000
Units affected:	291,652

Description:: ON CERTAIN SEDANS AND WAGONS, THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.
Consequeces:: THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP) OR TAIL LAMPS. A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Corrective action:: DEALERS WILL INSTALL TWO NEW TAIL LAMP REINFORCING SOCKET ADAPTERS AND SOCKETS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876.
Notes:: GM RECALL NO. 05052.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2002 SATURN LS Complaints
Rear tail lights will not work. Have checked all fuses relays,and even changed the turn signal switch. My car is currently at the garage. Original appointment was only for inspection. Mechanic has not yet located the issue. Also has no dash lights. Parking lights. Had I known this in advance would have returned car immediately.;
2003 SATURN L200 Complaints
The contact owns a 2003 Saturn L200. The contact stated that while his wife was driving 45 MPH, an abnormal whirling sound was coming from the vehicle and the vehicle stalled without warning. The contact's wife was unable to restart the vehicle and with the assistance of a police officer, she coasted the vehicle off to the shoulder of the roadway. The vehicle was then towed to an independent mechanic where the vehicle was diagnosed with a defective timing chain which resulted in engine failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was unknown.;
2004 SATURN L300 Complaints
My vehicle is leaking fuel from the fuel pump. I can see the fuel collecting on the side of the fuel tank from the top of the tank where the fuel pump is located. This issue has been releasing gas fumes around my car and occasionally in the cabin. This not only makes my car invalid for emissions testing in many states across the country, it also poses a risk to the overall safety of the vehicle. This issue is extremely common on these cars, I have seen many reports on Saturn forums talking about the issue and just how dangerous / expensive it has been for them to deal with. Due to the way GM has made this car, you cannot replace this part without dropping the exhaust and fuel tank.;