ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS

Oct 06, 2005 — Recall Campaign #05V460000

ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.

The recall was influenced by the manufacturer with about 256,409 units affected.

See recall notice

NHTSA Safety Recall Notice

05V460000

Manufacturer:	Chrysler (FCA US, LLC)
Recall date:	October 06, 2005
NHTSA Campaign #:	05V460000
Units affected:	256,409

Description:: ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequeces:: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Corrective action:: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Notes:: DAIMLERCHRYSLER RECALL NO. E14.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236; (TTY:1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2005 DODGE DAKOTA Complaints
The contact owns a 2005 Dodge Dakota. The contact stated that the vehicle had been shipped to them. While the vehicle was parked, the contact inspected the vehicle and observed that the frame was severely corroded. The contact also noted that the frames of all the vehicle doors were corroded as well. The vehicle was taken to an independent mechanic, where it was not formally diagnosed; however, the mechanic informed the contact that the frame was severely corroded, the vehicle was structurally compromised, and they were unsure whether the vehicle could be repaired. The vehicle was not repaired. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 81,892.;
2006 CHRYSLER 300 Complaints
The contact owns a 2006 Chrysler 300. The contact stated that while driving at undisclosed speeds, the vehicle shut off unexpectedly. The contact stated that the vehicle sputtered and stalled after refueling. There was an abnormal rumbling sound coming from the vehicle. The contact waited for 30 minutes to restart the vehicle. The accelerator pedal was depressed; however, the vehicle failed to respond as needed. While driving and making a turn, the vehicle stalled. There were unknown warning lights illuminated. The contact associated the failure with NHTSA Campaign Number: 14V002000 (Fuel System, Gasoline). The local dealer was contacted and informed the contact that the vehicle could not be repaired. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was unknown.;
2006 DODGE CHARGER Complaints
I have a beautiful 2006 dodge daytona charger with 5.7L Hemi engine that has failed with 170,000 miles. It has been impeccably maintained with on time oil changes using Mobil 1 synthetic oil. The problem is the roller on the lifter for cylinder # 4 locked up and wiped the lobe off the camshaft...So now theres a misfire and the engine needs a rebuild! I know nothing lasts forever BUT.... most engines now a days make 200,000 no problem and most go well beyond that if maintained properly. I was expecting the same for this engine but This well-known problem finally struck me... I have had my lifetime warranty denied because the cost of the engine exceeds the value of the car so there lifetime warranty is a very mis leading and really an out rite lie!!! Chrysler/Stellantis knows all about these hemi engines failing but is leaveing its customers holding the bag! I think you should do an investigation do the huge number of failures!!!;
2006 DODGE DURANGO Complaints
Vehicle: 2006 Dodge Durango VIN: [XXX] Issue Type: Fuel System / Safety Hazard Description: During refueling, the vehicle repeatedly shuts the pump off and then sprays gasoline back out of the filler neck, creating a fire and injury hazard. This is a known defect covered under Dodge Customer Satisfaction Notification X39, which extends warranty coverage for the inlet check valve / ORVR failure on 2006–2008 Durango models. The symptoms match the documented defect exactly: pump shutoff, fuel expulsion, and fuel spray. This occurs at multiple stations and with different pumps. Stellantis customer service and local dealers have been unresponsive and will not acknowledge X39 unless forced. The defect poses a clear safety risk to me and others nearby during refueling. I am requesting NHTSA involvement to ensure Stellantis honors the X39 warranty extension and addresses this fuel system hazard. Safety Risk: Gasoline sprays out under pressure, contacting the vehicle, ground, and the person refueling. This is a fire hazard and exposes the user to fuel on skin and clothing. The condition is unpredictable and dangerous. Requested Action: Require Stellantis to inspect and repair the vehicle under CSN X39 and ensure compliance with the documented unlimited-time warranty extension for this defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);
2006 DODGE MAGNUM Complaints
vehicle engine codes were all corrected properly in hopes of fixing the stalling issues. the vehicle was seemingly better for a few days. upon driving the vehicle on the highway at normal highway speed, the vehicle suddenly began flickering and shutting off and on. the vehicle would shut off and on rapidly. each time the vehicle turned back on it would accelerate causing the vehicle to jolt forward and stop rapidly. the car would not allow me to brake safely. the vehicle behind was within inches of a collision but their quick response to slam on their brakes and swerved to the shoulder thankfully missed. this is not an isolated event. speaking to other hemi 5.7 vehicle owners this is a very common issue. I had a baby in a carseat in the backseat who was jolted around slamming the back of his head into his car seat. this is so dangerously unsafe. not dealership can find the problem even after replacing every part possible on these vehicles.;