ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK

Nov 09, 2005 — Recall Campaign #05V515000

ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).

The recall was influenced by the manufacturer with about 123,206 units affected.

See recall notice

NHTSA Safety Recall Notice

05V515000

Manufacturer:	Ford Motor Company
Recall date:	November 09, 2005
NHTSA Campaign #:	05V515000
Units affected:	123,206

Description:: ON CERTAIN PASSENGER VEHICLES, THE STRAPS THAT SECURE THE FUEL TANK TO THE VEHICLE BODY MAY BREAK, CAUSING THE FUEL TANK AND FUEL TANK HEAT SHIELD TO DROP ON THE DRIVESHAFT (ALL WHEEL DRIVE VEHICLES) OR EXHAUST SYSTEM (FRONT WHEEL DRIVE VEHICLES).
Consequeces:: IF THIS HAPPENS, DRIVERS MAY NOTICE A NOISE OR A FUEL LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Corrective action:: DEALERS WILL REPLACE BOTH FUEL TANK STRAPS. THE RECALL BEGAN ON DECEMBER 1, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes:: FORD RECALL NO. 05S37.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2005 FORD FIVE HUNDRED Complaints
The contact owns a 2005 Ford Five Hundred. The contact stated that while driving at various speeds, the vehicle made an abnormal knocking sound. The vehicle was taken to two independent mechanics, where the flywheel was replaced twice with used parts because the part had been discontinued. The contact stated that while her son was driving approximately 20 MPH, the vehicle stalled. The check transmission warning light, the check engine warning light, and other unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was able to restart but was undrivable. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 80,000.;
2005 FORD FREESTYLE Complaints
Our 2005 Ford Freestyle often accelerates or surges forward on its own when applying the brake or parking. It is a very dangerous malfunction that looks to be a wide spread problem for this make and model (based on online reports).;
2005 MERCURY MONTEGO Complaints
This vehicle had a recall performed on it. In the recall, it states that the door does not latch properly in colder weather. Vehicle has been brought to the dealership. They have stated that they have performed the recall service. But when the car is driven, the door still does not latch which causes a safety issue because it will open randomly. This has been brought to Ford’s attention and they have not been able to help with a solution.;