CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES

Jul 13, 2006 — Recall Campaign #06V254000

CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER OPERATOR PULLS THE DASH VALVE BUTTON.

The recall was influenced by the Office of Defects Investigation with about 1,184 units affected.

See recall notice

NHTSA Safety Recall Notice

06V254000

Manufacturer:	Isuzu Motors Limited
Recall date:	July 13, 2006
NHTSA Campaign #:	06V254000
Units affected:	1,184

Description:: CERTAIN MEDIUM DUTY TRUCKS EQUIPPED SR-7 BENDIX BRAKE VALVES, THE CHECK VALVE INSIDE THE VALVE CAVITY MAY NOT PROPERLY SET, CAUSING INTERNAL AIR LEAKAGE. IF THE CHECK VALVE DOES NOT PROPERLY SEAT, THE RESULTING LEAKAGE CAN CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER OPERATOR PULLS THE DASH VALVE BUTTON.
Consequeces:: THE DELAYED PARKING BRAKE APPLICATION CAN OCCUR WITHOUT WARNING, LEADING TO UNINTENDED VEHICLE ROLLAWAY INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL INSPECT THE VALVES AND REPLACE IT FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.
Notes:: GM RECALL NO. 06054. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2006 CHEVROLET C7500 Complaints
MONDAY, 10/15/07 VEHICLE WOULD NOT START IN THE A.M. VEHICLE WAS JUMPED STARTED PROCEEDED IMMEDIATELY TO DEALER. EXPLAINED TO SERVICE DEPT VEHICLE WOULD NOT START HOWEVER, ALL INTERIOR LIGHTS WERE WORKING BUT VEHICLE WOULD NOT START. SERVICE DEPT HAD VEHICLE ALL DAY COULD NOT FIND ANYTHING WRONG. BATTERY WAS CHECKED OUT IT WAS OK. MONDAY NIGHT (10/15/07) VEHICLE WOULD NOT START AFTER BEING IN SERVICE ALL DAY. VEHICLE WAS JUMPED STARTED AGAIN TO GET ME HOME. TUESDAY (10/16/07) AM VEHICLE STARTED WENT TO WORK. CHECKED VEH AROUND 10:30 AM VEHICLE WOULD NOT START. VEHICLE HAD TO BE JUMPED STARTED IMMEDIATELY WENT TO DEALERSHIP COMPLAINING OF THE PROBLEM. A DEVICE WAS PLACED IN VEHICLE CHECKING THE MILLA AMP DRAW. TRACED PROBLEM TO FAULTY GATE MODULE WAS DRAINING ON BATTERY (IN OTHER WORDS TERRORIZING BATTERY) PREVENTING VEHICLE FROM STARTING. CALLED GM CUSTOMER SERVICE TO COMPLAIN ABOUT BEING REIMBURSED. WORDS THAT WERE USED BY GM WERE MALFUNCTION, FAULTY PART. I STRONGLY FEEL THIS IS A DEFECTIVE PART. TAILGATE MODULE & BATTERY HAD TO BE REPLACED. I ASKED FOR ORIGINAL PART BACK IN CASE IT NEEDS TO BE INSPECTED. *TR;
2006 CHEVROLET C8500 Complaints
CHECK ENGINE LIGHT ON, OIL PRESSURE LIGHT ON, REDUCE ENGINE POWER LIGHT ON, SERVICE VEHICLE SOON LIGHT ON, ALL INTERIOR AND EXTERIOR LIGHTS WERE RUNNING, CAR WOULD NOT HOLD A CHARGE. CAR TOWED INTO SHOP WHERE THEY CHANGED THE BATTERY. *NM;
2006 CHEVROLET KODIAK Complaints
TL* THE CONTACT OWNS A 2006 CHEVROLET KODIAK. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, A STRANGE NOISE WAS HEARD FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE CALIPER BRACKETS HAD BECOME DETACHED FROM THE VEHICLE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 10,000. UPDATED 11/19/13*LJ;
2006 CHEVROLET T-SERIES Complaints
WATER FROM OUTSIDE LEAKS INTO TRUCK BEHIND DASHBOARD, WHEN A/C IS RUNNING. WATER LEAKS ONTO CARPET - CENTER OF TRUCK UNDER DASH, TO CARPET UNDER GAS PEDDLE. WATER COULD BE LEAKING ALSO ONTO INTERIOR ELECTRICAL WIRING BEHIND DASHBOARD, HAVE SOME CONCERN FOR DAMAGE TO INTERIOR CAUSED BY WATER LEAKING INTO VEHICLE. *NM;
2006 GMC T-SERIES Complaints
AFTER 9 INCHES OF RAIN REPORTED YESTERDAY FOR NORTH MIAMI , FLORIDA HUMMER H-3 FOUND WITH LEAKING BIG AMOUNT OF WATER IN DASHBOARD AND FLOOR OF THE CAR. HUMMER H-3-YR 2006. *AK;