CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER

Oct 31, 2006 — Recall Campaign #06V417000

CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.

The recall was influenced by the manufacturer with about 794 units affected.

See recall notice

NHTSA Safety Recall Notice

06V417000

Manufacturer:	General Motors, LLC
Recall date:	October 31, 2006
NHTSA Campaign #:	06V417000
Units affected:	794

Description:: CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequeces:: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Corrective action:: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
Notes:: GM RECALL NO. 06102.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2004 CHEVROLET SILVERADO 2500 Complaints
The contact owns a 2004 Chevrolet Silverado 2500. The contact stated that while driving 60-65 MPH, the vehicle experienced reduced power and went into LIMP Mode. The contact pulled over to the side of the road. The contact turned off and restarted the vehicle after several minutes, as per the Owner's Manual. The transmission warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that it could take 1-2 weeks to diagnose the vehicle, and several months to repair the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a claim was filed. The failure mileage was approximately 50,000.;
2005 CHEVROLET TAHOE Complaints
P 285 50 R20 Cooper Discoverer HT blew out on Mass Tpke I 90 EB on Aug 8 @ approx 7:00pm while driving. Whole center section came off right rear tire leaving only the sidewalls on the rim. was able to manuever vehicle off I 90 EB off to the shoulder. Vehicle was towed of Turnpike to safe location. Attempting to reach Cooper to advise and see if any recourse for reimbursement for blown tire and remaining tires on vehicle with same production date on tire 0f 3919; DOT UT6K CLD;
2005 GMC SIERRA 3500 Complaints
The contact owns a 2005 GMC Sierra 3500. The contact stated that while driving at an undisclosed speed, the vehicle failed to come to a stop while the brake pedal was depressed. The contact stated that the brake pedal felt loose. The ABS warning light was illuminated. The contact was able to bring the vehicle to a complete stop and the contact became aware of a brake fluid leak coming from under the hood, and that both front and rear brake lines were rusted. An appointment with the dealer was scheduled to inspect the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.;
2005 PONTIAC MONTANA Complaints
When I start the engine & try to put in another it it nearly impossible. With engine on, it smells of gasoline! I'm afraid I will die from the fumes. Transmission only goes up to 20 mph. I know there is a gas leak and I want others to be notified before my family or someone else's family catch fire and burn to death! If I have to run the heater then it takes power from the engine/transmission and I can only go 10mph. When I am in on on the highway the van will shut off. It shut off out of nowhere and I almost lost my life that day!;
2006 BUICK LACROSSE Complaints
Vehicle rear-ended at high rate of speed. Impact included rollover. Driver was buckled but seatbelt and/or seat failure and no air bag deployment for either occupant. Serious bodily injury occurred. Vehicle on hold pending further police investigation and scene reconstruction by multiple agencies.;