ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE

Mar 26, 2007 — Recall Campaign #07V139000

ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.

The recall was influenced by the manufacturer with about 33,169 units affected.

See recall notice

NHTSA Safety Recall Notice

07V139000

Manufacturer:	Ford Motor Company
Recall date:	March 26, 2007
NHTSA Campaign #:	07V139000
Units affected:	33,169

Description:: ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.
Consequeces:: LACK OF POWER OR ROUGH OPERATION, UNUSUAL NOISES FROM THE ENGINE OR EXHAUST, WHITE SMOKE FROM THE EXHAUST, AND POTENTIALLY A VISIBLE FLAME OUT THE TAILPIPE CAN OCCUR.
Corrective action:: DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes:: FORD RECALL NO. 07S49.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2008 FORD F-250 Complaints
All the fiberglass Bkack trim and the Gray door panels and the middle armrest are causing skin irritation to any person that come in touch with them. I havee owned this Truck for so many years, the problem started about 4 years ago, since I only use it for towing the camper I have ignored the issue for sure this very inconvenient to sell a vehicle with only 87k because of the manufactur cheap trim or other oweners didn't complain and ignored the issue. I have not taken the Truck to the Ford dealer because I have know doubt in my mind that they will tell me it's an 18 years old vehicle get another one. Yes I have the vehicle available for inspection at anytime. Thank you very much for taking the time to read my complaint.;
2008 FORD F-350 Complaints
Items in my bed and liner caught on fire. Engine regeneration for emissions got so hot melted all of the bed liner and caught a new large tv on fire. Ford has a glue on heat shield under bed which fell off. Exhaust gets so hot it caught on fire. They should have put a metal fixed plate or something fixed no a cheap glue on piece of foil. I inspected other trucks all missing!;
2008 FORD F-450 SD Complaints
The contact owns a 2008 Ford F-450. The contact stated while driving at approximately 65 MPH, the transfer case exploded, and the front windshield shattered. No injuries were sustained; however, several other vehicles sustained cosmetic damage. No warning light was illuminated. A Police report was filed. The vehicle was not drivable and was towed to an independent mechanic for a diagnostic test. The contact was informed that the transfer case, drive shaft assembly, fuel injection pump, fuel lines, and transmission wiring harness needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and confirmed that there was no recall associated with the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 164,176.;
2008 FORD F-550 SD Complaints
Brought the truck in to ford and they told me that paint lining from the tank may of gone into the fuel lines and system so they suggested that we replace the tank and they also replaced 2 injectors and the wiring harness for the injectors and reset the check engine light drove fine till the check engine light come on then its in limp mode and only drives at 40 miles per hour it is unsafe to drive on the highway and I do like this truck;