ON CERTAIN TRUCKS, THE REAR DRIVE AXLE HOUSING WAS MANUFACTURED WITH STEEL BELOW THE SPECIFIED THICKNESS

Apr 10, 2007 — Recall Campaign #07V154000

ON CERTAIN TRUCKS, THE REAR DRIVE AXLE HOUSING WAS MANUFACTURED WITH STEEL BELOW THE SPECIFIED THICKNESS AND, AS A RESULT, IT COULD DEVELOP A CRACK.

The recall was influenced by the manufacturer with about 67 units affected.

See recall notice

NHTSA Safety Recall Notice

07V154000

Manufacturer:	General Motors, LLC
Recall date:	April 10, 2007
NHTSA Campaign #:	07V154000
Units affected:	67

Description:: ON CERTAIN TRUCKS, THE REAR DRIVE AXLE HOUSING WAS MANUFACTURED WITH STEEL BELOW THE SPECIFIED THICKNESS AND, AS A RESULT, IT COULD DEVELOP A CRACK.
Consequeces:: IF A CRACK DEVELOPS AND IS NOT DETECTED AND REPAIRED, THE OUTBOARD END OF THE HOUSING COULD EVENTUALLY SEPARATE, ALLOWING THE HUB, AXLE SHAFT, OR WHEEL AND BRAKE ASSEMBLY TO SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL INSPECT AND REPLACE THE AXLE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 12, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.
Notes:: GM RECALL NO. 07079.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2007 CHEVROLET KODIAK Complaints
2007 C4500 KODIAK WITH DUMP BODY 1. EMERGENCY BRAKE FAILED TO HOLD TRUCK WHILE IN GEAR WITH MOTOR RUNNING: 2. FACTORY INSTALLED ELECTRIC (TRAILER BRAKE ) CONTROLLER FAILED, & TURNED ON & OFF AT RANDOM: 3. THE TRUCKS SERVICE BRAKES FAILED , WHILE TRYING TO STOP THE TRUCK, (THEN THE TRUCKS BRAKE WARNING LIGHTS & AUDIBLE ALARMS CAME ON, THEN THE ALARMS FAILED TO COME ON LATER THAT NIGHT,,, WHILE THE BRAKE PEDDLE WENT CLEAR TO THE FLOOR BOARDS: 4. THE GM (STOP LAMP SWITCH) WAS REPLACED (CODE) ( DTC # C0164 ) WITH PART NUMBER #(15128874) , (WHILE THE DEFECTIVE PART WAS NOT RETURNED TO ME FOR INSPECTION) 5. WHILE THIS (FEBRUARY 22ND, 2007 TECH. SERVICE BULLETIN) (((( #07-05-22-001: BRAKE LIGHT SWITCH INOPERATIVE, BRAKE WARNING BUZZER SOUNDING AND BRAKE WARNING LIGHT ON))) DESCRIBED PROBLEMS WITH THE 2006 KODIAK C4500 THERE SHOULD HAVE BEEN A FACTORY RECALL DUE TO POSSIBLE BRAKE FAILURES, DUE TO WIRING THE SERVICE BRAKES TO THE ELECTRIC TRAILER BRAKES IN FACTORY AFTER MARKET INSTALLATIONS: 6. SINCE MY SERVICE BRAKES FAILED, MY BRAKE WARNING ALARMS FAILED LATER THAT NIGHT, MY EMERGENCY BRAKE WAS MIS ADJUSTED, & BY WIRING THE ELECTRONIC TRAILER BRAKES TO THE SERVICE BRAKE (STOP LAMP SWITCH), WHICH SHORTED OUT THIS CONNECTION,, BY DRAWING TOO MUCH CURRENT THRU THE STOP LAMP SWITCH: DID CAUSE A SITUATION OF TOTAL BRAKE FAILURE, WITH NO ALARMS: 7. THIS 2007 C4500 WITH ELECTRIC BRAKE CONTROLLER SHOULD BE RECALLED WITH A FACTORY DEALER INSPECTION, CONCERNING THE DEFECTIVE SERVICE BRAKE STOP LAMP SWITCH, & HOW THE ELECTRIC TRAILER BRAKE IS WIRED TO THE BRAKE PEDAL, ACCORDING TO THE (2) OR MORE GM BRAKE SERVICE BULLETINS, BEFORE THIS TRUCK WAS SOLD (NEW) TO ME: THE DEFECTS IN THE BRAKE WARNING SYSTEM,.THE SERVICE BRAKES, THE ELECTRIC TRAILER BRAKES, & EMERGENCY BRAKE, HAVE CAUSED ME TO FILE A WASHINGTON STATE LEMON LAW CLAIM: *TR;
2007 GMC TOPKICK Complaints
TL*THE CONTACT OWNS A 2007 GMC TOPKICK. THE CONTACT STATED THAT THERE WAS A WIRING ERROR RELATED TO THE UPFITTER. WHILE THE BODY WAS BEING PLACED ON THE VEHICLE, THEY CLIPPED THE WIRING THAT WAS SUPPLIED FROM GM. THE TAIL LIGHTS STOPPED WORKING DUE TO THE CLIPPED WIRING. THE FAILURE AND CURRENT MILEAGES WERE 5,000. UPDATED 3/16/09 *CN THE CONSUMER STATED THE TAILLIGHTS, MARKER LIGHTS AND DASH LIGHTS WERE ALL OUT. THE PROBLEM WAS DETERMINED TO BE A BLOWN FUSE. UPDATED 03/19/09.(KB;