ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR C11, C13 OR C15 ENGINES

Jun 28, 2007 — Recall Campaign #07V279000

ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR C11, C13 OR C15 ENGINES, THE OIL FILL CAP CAN BECOME DISLODGED DUE TO CAP DAMAGE OR IMPROPER INSTALLATION AND BECOME LODGED IN THE U-JOINT OF THE STEERING DRIVELINE AND STEERING GEAR.

The recall was influenced by the manufacturer with about 28,968 units affected.

See recall notice

NHTSA Safety Recall Notice

07V279000

Manufacturer:	PACCAR Incorporated
Recall date:	June 28, 2007
NHTSA Campaign #:	07V279000
Units affected:	28,968

Description:: ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR C11, C13 OR C15 ENGINES, THE OIL FILL CAP CAN BECOME DISLODGED DUE TO CAP DAMAGE OR IMPROPER INSTALLATION AND BECOME LODGED IN THE U-JOINT OF THE STEERING DRIVELINE AND STEERING GEAR.
Consequeces:: IF THE CAP BECOMES DODGED IN THIS AREA, IT MAY RESULT IN DIFFICULTY STEERING THE VEHICLE OR CAUSE COMPLETE STEERING LOCK-UP INCREASING THE RISK OF A CRASH.
Corrective action:: PACCAR IS WORKING WITH CATERPILLAR TO REPAIR THESE VEHICLES. REVISED OIL CAP RETENTION BASED ON THE ENGINE MODEL/CONFIGURATION WILL BE INCORPORATED TO PREVENT STEERING LOCK-UP. THE RECALL BEGAN DURING DECEMBER 2007. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986 OR KENWORTH AT 425-828-5440.
Notes:: KENWORTH RECALL NO. 07KWB.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2007 KENWORTH T2000 Complaints
AFTER RESEARCHING MY PROBLEM WITH THIS TRUCK I WAS AMAZED TO DISCOVER THAT IT IS A COMMON PROBLEM WITH KENWORTH AND PETTERBULT TRUCK'S! THE FRAME RAILS, THE VERY FOUNDATIONS OF THESE TRUCK'S ARE DEFECTIVE RIGHT OUT OF THE FACTORY! A KENWORTH BODY MAN WORKING FOR KENWORTH TOLD ME THAT THEY DON'T PUT ENOUGH PAINT ON THE FRAME THAT IS ASSEMBLED AND THEN PAINTED AS ONE UNIT ! IN HIS OPINION ALL PARTS SHOULD BE PANITED AND THEN ASSEMBLED! I AGREE. I'VE GOT A TRUCK THAT NEEDS TWO NEW FRAME RAILS THAT WILL COST $14000.00 TO REPAIR TRUCK! THIS IS UNACCEPTABLE! AND I'M TOLD THAT THE TRUCK ISN'T SAFE FOR THE ROAD! THE RAILS ARE RUSTING OUT! WHAT IF NO ONE CAUGHT THIS! I'M TOLD THAT IF IT COMES APART THERE'S NO CONTROLLING THE TRUCK! KENWORTH TELLS ME THAT THEY ARE CHANGING FRAME RAILS ALL THE TIME. THIS IS EVIDENCE TO ME THAT THEY NEED TO BE MADE TO DO A FACTORY RECALL ON THERE TRUCK'S THAT APPARENTLY HAS SHOTTY WORKMANSHIP! THE SAFTY OF THE MOTTERING PUBLIC IS AT RISK! AND KENWORTH AND PETERBUILT SHOULD BE HELD ACCOUNTABLE, THANK YOU AND I HOPE TO HEAR FROM YOU, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).;
2007 KENWORTH T600 Complaints
TL* THE CONTACT OWNS A 2007 KENTWORTH T600 WITH GOODYEAR SUPER SINGLE TIRES, LINE SIZE 445/50R/22.5 AND THE DOT NUMBER GSWR39965. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH THE REAR DRIVER SIDE TIRE BLEW OUT. THE CONTACT REPLACED THE TIRE WITH THE SPARE AND SHORTLY AFTER THE FAILURE RECURRED. ALSO, THE REAR PASSENGER SIDE TIRE BLEW OUT THREE DIFFERENT TIMES AND THE FRONT AND REAR DRIVERS SIDE TIRES BLEW OUT AS WELL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.;
2007 KENWORTH T800 Complaints
TL*THE CONTACT DROVE A 2007 T800 KENWORTH TRUCK. WHEN DRIVING APPROXIMATELY 10 MPH IN REVERSE AND TRYING TO LOCK THE TRAILER IN PLACE, THE FIFTH WHEEL HANDLE FAILED TO LOCK WHICH CAUSED THE FIFTH WHEEL TO SLIDE. THE MECHANIC TOLD HER THAT SHE WOULD NEED TO MANUALLY LOCK THE TRAILER. SHE ALSO STATED THAT ALL OF THE TRUCKS WERE EXPERIENCING THE SAME FAILURE AND THE COMPANY WAS NOT WILLING TO CORRECT THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 170,950.;