ON CERTAIN MOTORCYCLES EQUIPPED WITH AN OPTIONAL ACCESSORY LUGGAGE RACK

Dec 12, 2007 — Recall Campaign #07V562000

ON CERTAIN MOTORCYCLES EQUIPPED WITH AN OPTIONAL ACCESSORY LUGGAGE RACK, UNDERSIZED WASHERS WERE USED WHICH PREVENTS THE SLIDING CARRIAGE FROM MOVING AS INTENDED.

The recall was influenced by the manufacturer with about 3,698 units affected.

See recall notice

NHTSA Safety Recall Notice

07V562000

Manufacturer:	Triumph Motorcycles America, Ltd.
Recall date:	December 12, 2007
NHTSA Campaign #:	07V562000
Units affected:	3,698

Description:: ON CERTAIN MOTORCYCLES EQUIPPED WITH AN OPTIONAL ACCESSORY LUGGAGE RACK, UNDERSIZED WASHERS WERE USED WHICH PREVENTS THE SLIDING CARRIAGE FROM MOVING AS INTENDED.
Consequeces:: REDUCED STABILITY CAN OCCUR IF THE MOTORCYCLE IS RIDDEN WITH THE FITTED ACCESSORY, EXCEEDED MAXIMUM WEIGHT, AND AT SPEEDS FAR IN EXCESS OF THE 80 MPH LIMIT WARNING, INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL INSPECT THE ACCESSORY RACKS FOR LATERAL MOVEMENT. THOSE RACKS NOT DISPLAYING ANY MOVEMENT WILL BE REPAIRED. THE RECALL BEGAN ON FEBRUARY 8, 2008. OWNERS MAY CONTACT TRIUMPH AT 1-678-854-2010.
Notes:: TRIUMPH RECALL NO. 387.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2008 TRIUMPH SPRINT ST 1050 Complaints
While traveling at approximately 55 mph under normal road conditions, the rear tire experienced a sudden and catastrophic failure. I felt the tire fail first, followed by an immediate loss of stability. The tire split down the center of the tread without warning. There were no prior symptoms, warning signs, or handling issues before the failure. During the loss of control, I then felt the rear of the motorcycle drop further. After the crash, a rear suspension linkage component was found to be cracked at the mounting point. It is UNKNOWN whether the linkage failure occurred before or as a result of the crash sequence, but it was not felt prior to the tire failure. The tire, 180/55ZR17 73W, had been installed in August and had less than 1,500 miles of use. Tire pressure was set to manufacturer-recommended levels prior to operation. The failed tire is available for inspection, and the damaged rear linkage component remains on the motorcycle. The failure created an immediate safety hazard, resulting in a crash and injuries to a passenger. The motorcycle sustained severe damage and is considered a total loss. No prior warnings, messages, or indicators were present before the failure.;
2008 TRIUMPH TIGER 1050 CCM ABS Complaints
THE LOW BEAM IS VERY DIM AND APPEARS FOGGY INSIDE THE LENS. IT APPEARS THE REFLECTOR BEHIND THE LAMP IS LOOSING ITS ABILITY TO REFLECT THE LIGHT ONTO THE ROAD. THE HEADLIGHT IS DEFECTIVE. BOTTOM LINE: THE LIGHT PATTERN ON THE ROAD IS ALMOST NONEXISTENT. IT IS DANGEROUS TO RIDE THE BIKE AT NIGHT. THE RIDER CANNOT SEE THE ROAD IN THE DARK. THE FACTORY HEADLIGHT IS DEFINITELY DEFECTIVE. *TR;