FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO

Feb 04, 2008 — Recall Campaign #08V051000

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

The recall was influenced by the manufacturer with about 225,000 units affected.

See recall notice

NHTSA Safety Recall Notice

08V051000

Manufacturer:	Ford Motor Company
Recall date:	February 04, 2008
NHTSA Campaign #:	08V051000
Units affected:	225,000

Description:: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequeces:: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Corrective action:: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Notes:: FORD RECALL NO. 08S01.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

1993 FORD BRONCO Complaints
MY 1993 FORD BRONCO HAS AN ESOF (ELECTRONIC SHIFT ON THE FLY) TRANSFER CASE. WITH FOUR WHEEL DRIVE ENGAGED, ON ROAD AND OFF, WHENEVER THE VEHICLE IS COASTING THE TRUCK WILL SUDDENLY ACT LIKE IT IS NO LONGER IN GEAR. SHIFTING INTO PARK AND AND BACK WILL NOT CHANGE ANYTHING. THE TRUCK MUST BE TAKEN OUT OF FOUR WHEEL DRIVE IN ORDER TO START DRIVING AGAIN. I BELIEVE THIS TO BE DANGEROUS AS IT COULD ALLOW ME TO NOT REACT IN THE CASE OF AN EMERGENCY. IT THINK THAT IT IS A SIMILAR PROBLEM TO THE RECALL 93V089000.;
1993 FORD F-150 Complaints
The contact owns a 1993 Ford F-150. The contact became aware that the VIN was included in NHTSA Campaign Number: 05V017000 (Vehicle Speed Control); however, the part to do the recall repair was not yet available. The contact stated that while replacing the brake master cylinder, the contact noticed that there was brake fluid leaking onto a connector. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and contacted the dealer. The failure mileage was approximately 156,000. Parts distribution disconnect.;
1993 FORD F-250 Complaints
TL* THE CONTACT OWNS A 1993 FORD F-250. WHILE THE CONTACT WAS FUELING THE VEHICLE, THE FUEL CAP SHRANK AND FUEL SPEWED FROM THE FUEL TANK. THE FAILURE OCCURRED WHENEVER HE ATTEMPTED TO FUEL THE FRONT TANK FIRST. AS THE FUEL TRAVELED TO THE REAR TANK, IT SPEWED OUT. THE CONTACT STATED THAT THE FAILURE WAS A FIRE HAZARD. THE CONTACT DROVE THE VEHICLE TO FUTURE FORD OF ROSEVILLE (650 AUTOMALL DR, ROSEVILLE, CA 95661, (888) 656-7577), BUT THE MECHANICS REFUSED TO SERVICE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 250,000.;
1993 FORD F-350 Complaints
TL* THE CONTACT OWNS A 1993 FORD F-350 EQUIPPED WITH BCT HI-RUN TIRES, SIZE L235/85R16 (NA). WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIRE TREADS WERE SEPARATING FROM THE TIRES AND THE TIRES NEEDED TO BE REPLACED. WHILE AT THE INDEPENDENT MECHANIC, THE OTHER THREE TIRES BLEW OUT. THE TIRES WERE NOT REPAIRED. THE TIRES WERE NOT ORIGINAL EQUIPMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 190,000 AND THE TIRE FAILURE MILEAGE WAS 4,000. THE VIN AND DOT NUMBER WERE NOT PROVIDED.;
1993 FORD F-450 SD Complaints
DUEL TANKS IN VEHICLE AND ONE TANK EMPTIES INTO OTHER, CAUSING ONE TO OVERFLOW. IT'S CAUSED BYA CROSS VALVE NOT FUNCTIONING, SHUTING OFF FROM NON OPERATING TANK. REPAIR COST IS $800. DEALER IS NOT AUTHORIZING REPAIRS.*AK;