VOLVO IS RECALLING 1,114 MY 2007 C30, C70, S40, AND V50 PASSENGER VEHICLES

Mar 05, 2008 — Recall Campaign #08V101000

VOLVO IS RECALLING 1,114 MY 2007 C30, C70, S40, AND V50 PASSENGER VEHICLES. A SOFT ANODIZED LAYER IN THE MASTER CYLINDER MAY TRIGGER EARLY WEAR ON A RUBBER SEAL THAT CAN RESULT IN INTERNAL LEAKAGE OF BRAKE FLUID. IF AFFECTED, THE DRIVER MAY EXPERIENCE REDUCED BRAKE PERFORMANCE WHEN APPLYING AND MAINTAINING FORCE OF THE BRAKE PEDAL.

The recall was influenced by the manufacturer with about 1,114 units affected.

See recall notice

NHTSA Safety Recall Notice

08V101000

Manufacturer:	Volvo Car USA, LLC
Recall date:	March 05, 2008
NHTSA Campaign #:	08V101000
Units affected:	1,114

Description:: VOLVO IS RECALLING 1,114 MY 2007 C30, C70, S40, AND V50 PASSENGER VEHICLES. A SOFT ANODIZED LAYER IN THE MASTER CYLINDER MAY TRIGGER EARLY WEAR ON A RUBBER SEAL THAT CAN RESULT IN INTERNAL LEAKAGE OF BRAKE FLUID. IF AFFECTED, THE DRIVER MAY EXPERIENCE REDUCED BRAKE PERFORMANCE WHEN APPLYING AND MAINTAINING FORCE OF THE BRAKE PEDAL.
Consequeces:: THE CAPACITY TO BRAKE WILL GRADUALLY DETERIORATE FORCING THE DRIVER TO USE A HIGHER THAN EXPECTED FORCE ON THE BRAKE PEDAL WHEN COMPARED TO AN INTACT BRAKE SYSTEM. THE DETERIORATION CAN EVENTUALLY RESULT IN COMPLETE LOSS OF THE BRAKE SYSTEM FUNCTIONALITY INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL INSPECT THE MASTER CYLINDER. THE BRAKE MASTER CYLINDER AND BRAKE FLUID RESERVOIR WILL BE REPLACED AND CERTAIN BRAKE LINES CLEANED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 11, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Notes:: VOLVO RECALL NO. 194.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2007 VOLVO C30 Complaints
TL*THE CONTACT OWNS A 2005 FASHION 250 SCOOTER (NA). WHILE RIDING 55 MPH, THE CONTACT HEARD STRANGE NOISES COMING FROM THE MUFFLER. SHORTLY AFTERWARDS, THE DRIVESHAFT WOULD NOT MOVE AND THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO THE SHOP AND THEY REPAIRED THE EXHAUST AND DRIVESHAFT. SIX WEEKS LATER, THE FAILURE RECURRED. IN ADDITION, THE REAR WHEEL BEARINGS CAME APART AND CAUSED THE REAR WHEEL TO FLATTEN. THE VEHICLE WAS TAKEN TO BE REPAIRED AGAIN. THREE WEEKS LATER, THE FAILURE RECURRED. THE VIN, NUMBER OF CYLINDERS, POWERTRAIN, AND FUEL SYSTEM WERE UNKNOWN. THE FAILURE MILEAGE WAS 7,000 AND CURRENT MILEAGE WAS 8,400.;
2007 VOLVO C70 Complaints
I took my Volvo C70 into Niello Volvo Cars Sacramento on March 24, 2022. My invoice is attached (XXX) Recall 247 performed - tire pressure recall) Cassandra at Volvo ordered a new sticker at that appointment. Can you send me the new sticker as Niello Volvo Sacramento CA never followed up. Label is 11V508000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);
2007 VOLVO S40 Complaints
ON OR ABOUT 12/04/2019 DURING A FLASH RAIN STORM LAST WINTER, MY HUSBAND AND I WAS HEADED HOME ON THE 215 FWY NORTHBOUND IN SAN BERNARDINO, CA WHEN THE CENTER DOME AREA AND THE ELECTRIC SUNROOF INSIDE OUR CAR BEGIN POURING IN HUGE AMOUNTS OF VERY COLD RAIN WATER ON US AND ON THE DASHBOARD, STEREO CONSOLE, GEAR SHIFTER, FLOOR AND SEATS. UNTIL IT WAS SAFE TO EXIT THE FREEWAY, MY HUSBAND TRIED TO SOAK UP AS MUCH OF THE LEAKING RAINWATER AS HE COULD WITH HIS COAT BUT THE WATER CONTINUED TO POURING INTO THE CAR. ONCE IT WAS SAFE TO EXIT THE FREEWAY, WE PULLED INTO A GAS STATION AND EXAMINE THE SUNROOF TO MAKE SURE IT WAS SHUT PROPERLY, WHICH IT WAS, NOT UNDERSTANDING WHY THIS WAS HAPPENING, HE AND I USED AS MANY PIECES OF NAPKINS AND CLOTH THAT WE COULD FIND TO SOP UP AS MUCH WATER AS WE COULD AND AS BEST AS WE COULD. WE DROVE ON THE STREETS THE REMAINING FEW MILES TO GET HOME BECAUSE IT WAS MUCH SAFER TO DO SO AT THIS POINT. LATER, WE RESEARCHED AS MUCH AS WE COULD FIND OUT ABOUT THE PROBLEM VIA ONLINE COMPLAINTS AND REVIEWS FROM OTHER VOLVO OWNERS. WE THEN TRIED ONE OF THE FIXES OFFERED: CLEARING POTENTIAL DEBRIS FROM THE SUNROOF DRAIN HOSES. HOWEVER, WHEN WE TOOK THE CAR TO A DRIVE-THRU CARWASH SHORTLY AFTERWARDS, THE EXACT SAME THING HAPPEN. WE ARE LOOKING FORWARD TO SELLING THE VOLVO, BUT DUE TO THE LEAKY CENTER DOME AND SUNROOF, THERE IS NO WAY WE WILL CONSIDER SELLING THE CAR WITHOUT DISCLOSING THIS SAFETY ISSUE TO THE NEXT BUYER, EVEN THOUGH WHEN WE PURCHASED THE CAR IN 2013, THE DEALER WHO SOLD IT TO US DID NOT TELL US ABOUT THE SAFETY DEFECT. UNDOUBTEDLY, IF CAUGHT OFF GUARD WHILE DRIVING (I.E. WITHOUT A PASSENGER'S HELPING HAND), NOT KNOWING ABOUT THE DEFECT MAY RESULT IN A MAJOR ACCIDENT OR FATALITY. PLEASE HELP!!!;
2007 VOLVO V50 Complaints
CAR WAS PARKED FOR ABOUT 1 HOUR, INSIDE THE GARAGE, WHEN IT CAUGHT FIRE. NO EXPLANATIONS.;