BMW IS RECALLING 46 MY 2008 R1200 R, R1200 GS, AND R1200 GS ADVENTURE MOTORCYCLES

Jul 01, 2008 — Recall Campaign #08V290000

BMW IS RECALLING 46 MY 2008 R1200 R, R1200 GS, AND R1200 GS ADVENTURE MOTORCYCLES. DUE TO A MATERIAL DEFECT IN THE INTERMEDIATE SHAFT OF THE TRANSMISSION, THE SHAFT COULD BREAK. IF THIS OCCURRED, IT IS POSSIBLE FOR THE TRANSMISSION TO SEIZE.

The recall was influenced by the manufacturer with about 46 units affected.

See recall notice

NHTSA Safety Recall Notice

08V290000

Manufacturer:	BMW of North America, LLC
Recall date:	July 01, 2008
NHTSA Campaign #:	08V290000
Units affected:	46

Description:: BMW IS RECALLING 46 MY 2008 R1200 R, R1200 GS, AND R1200 GS ADVENTURE MOTORCYCLES. DUE TO A MATERIAL DEFECT IN THE INTERMEDIATE SHAFT OF THE TRANSMISSION, THE SHAFT COULD BREAK. IF THIS OCCURRED, IT IS POSSIBLE FOR THE TRANSMISSION TO SEIZE.
Consequeces:: IF THIS HAPPENED, LOCK-UP OF THE REAR TIRE COULD OCCUR. IT IS ALSO POSSIBLE FOR THE TRANSMISSION HOUSING TO BREAK. IF THIS HAPPENED, OIL COULD LEAK ONTO THE REAR WHEE, INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL REPLACE THE GEARBOX. THE RECALL BEGAN DURING AUGUST 2008. OWNERS SHOULD CONTACT BMW AT 1-800-331-1117.
Notes:: CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2008 BMW R1200 GS Complaints
WHILE TRAVELING DOWN THE FREEWAY THE FORWARD DRIVE SHAFT UNIVERSAL JOINT FAILED, LOCKING THE REAR WHEEL. THE SPINNING FORWARD END OF THE UNCONSTRAINED DRIVE SHAFT DAMAGED THE SWING ARM.;
2008 BMW R1200 GS ADVENTURE Complaints
MY BMW MOTORCYCLE WAS STATIONARY AT THE TIME BUT WITH A BRAKE FAILURE WARNING LIGHT INDICATED ON THE DISPLAY PANEL ONCE THE IGNITION WAS TURNED ON AND THE MOTORCYCLE ENGAGED TO BE RIDDEN THE MOTORCYCLE HAS LESS THAN 5,000 MILES ON IT. AFTER DOING SOME INTERNET RESEARCH, THE ABS MODULE IS COMMONLY FAILING AT AN ALARMING RATE THROUGHOUT THE USA AND ABROAD. THE ESTIMATED VALUE OF THE REPAIR WITH PARTS ALONE IS OVER $2,000 NOT INCLUDING LABOR. THESE UNITS SHOULD HAVE BEEN RECALLED BY THE MFG., BMW YET THERE HAS BEEN NO SUCH RECALL. BMW HAS MADE NO ACCOMMODATION TO EXTEND THE WARRANTY OR PROVIDE A REPLACEMENT DESPITE BEING WELL AWARE OF THE FAILURE RATE OF THESE ABS UNITS. OBVIOUSLY, A FAILURE OF THIS MODULE COULD CAUSE SEVERE INJURY OR DEATH WHILE OPERATING THE MOTORCYCLE.;
2008 BMW R1200 RT Complaints
THIS SERIES OF MOTORCYCLES HAS A COMMON PROBLEM WITH CRACKS IN THE THROTTLE PULLEYS ON THE THROTTLE BODY. FAILURE OF THIS PLASTIC PART WILL RESULT IN INSTANT LOSS OF POWER. I HAVE BEEN READING ABOUT THIS PROBLEM, AND DECIDED TO INSPECT THE TWO THROTTLE BODIES ON MY MOTORCYCLE AS A PRECAUTION. BOTH OF MINE WERE CRACKED. ONE OF THE PULLEYS HAS THREE CRACKS IN IT, AND WOULD LIKELY HAVE FAILED WITHIN A SHORT TIME. SEE PHOTOS INCLUDED WITH THIS REPORT.;