CHRYSLER IS RECALLING 5,509 MY 2008 300, DODGE MAGNUM, AND CHARGER VEHICLES

Jul 02, 2008 — Recall Campaign #08V295000

CHRYSLER IS RECALLING 5,509 MY 2008 300, DODGE MAGNUM, AND CHARGER VEHICLES. THE TORQUE RETENTION CRIMP FEATURE WAS MISSED DURING THE MANUFACTURE OF ONE LOT OF REAR AXLE HUB NUTS. THIS COULD CAUSE THE NUTS TO LOOSEN AND ALLOW THE HALFSHAFT TO DISENGAGE FROM THE WHEEL HUB.

The recall was influenced by the manufacturer with about 5,509 units affected.

See recall notice

NHTSA Safety Recall Notice

08V295000

Manufacturer:	Chrysler (FCA US, LLC)
Recall date:	July 02, 2008
NHTSA Campaign #:	08V295000
Units affected:	5,509

Description:: CHRYSLER IS RECALLING 5,509 MY 2008 300, DODGE MAGNUM, AND CHARGER VEHICLES. THE TORQUE RETENTION CRIMP FEATURE WAS MISSED DURING THE MANUFACTURE OF ONE LOT OF REAR AXLE HUB NUTS. THIS COULD CAUSE THE NUTS TO LOOSEN AND ALLOW THE HALFSHAFT TO DISENGAGE FROM THE WHEEL HUB.
Consequeces:: THIS COULD CAUSE THE VEHICLE TO LOSE POWER AND RESULT IN A CRASH WITHOUT WARNING.
Corrective action:: DEALERS WILL REPLACE THE REAR AXLE HUB NUTS. THE RECALL BEGAN ON JULY 21, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Notes:: CHRYSLER RECALL NO. H23.CUSTOMERS MAY CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY: 1-800-424-9153); OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2008 CHRYSLER 300 Complaints
I informed the dealership of ignition switch recall shortly after purchasing vehicle. The dealership stated " the VIN number shows no recalls". And that was it said there nothing showing up. I KNOW ignition switch is messed up because every time I would turn the car off I could still feel it running. I've had my car a year and now it will not crank due to ignition switch and now fuel air intake is also messing up and has caused cylinder 6 to miss fire. I have been without a vehicle for a month now and I need it fixed. When test driving the car, it would slow down as I was turning into a place of business and almost getting hit by another vehicle.;
2008 DODGE CHARGER Complaints
While driving on an expressway at 70 MPH , the car suddenly stopped and had no power. The gas gauge showed 1/4 tank of gas . Luckily we we able to cross lanes by coasting, to get off to the right. We had to be towed to a repair shop. The car was found to be Out of Gas ! This could have been a catastrophic accident ,or death ,had we not been able to get off the road !!;
2008 DODGE MAGNUM Complaints
Vehicle purchased pre-owned/used Sept.7th 2022 from dealership. Had 3 open recalls which were addressed. Said recall in question is 14v567000 ignition switch problem. I have had vehicle back at dealer now 3 times for continued problem of ignition sticking in the start mode as it keeps turning over & you have to physically turn ignition off or cycle it to stop the sticking problem. Dealer has changed the ignition module 3 times & problem still exist. 3 modules in less than a year. I do understand that this is not a dealer problem as they are only the repair facility. I have called Chrysler corporation with the issue & they keep sending me back to the dealer. This is a faulty/defective part that falls completely on Chrysler & there engineering, design, development, testing, & production that is clearly not being done or accomplished. Safety issue clearly needs to be addressed at the highest level. I have seen many complaints concerning this recall that appear to not have been fixed from repeated failures. 1st attempted fix recall Sept 2022, 2nd attempted fix, Oct 2022, 3rd attempted fix Aug 2023. I have just taken said vehicle back to the dealer to hopefully address this issue again.;