VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY

Jul 23, 2008 — Recall Campaign #08V329000

VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY VULCANIZED (CURED) AND DOES NOT MEET SPECIFICATIONS. IF THE POWER STEERING RETURN HOSE FAILS, A SUDDEN RUPTURE OF THE HOSE CAN OCCUR.

The recall was influenced by the manufacturer with about 1,020 units affected.

See recall notice

NHTSA Safety Recall Notice

08V329000

Manufacturer:	Volvo Car USA, LLC
Recall date:	July 23, 2008
NHTSA Campaign #:	08V329000
Units affected:	1,020

Description:: VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY VULCANIZED (CURED) AND DOES NOT MEET SPECIFICATIONS. IF THE POWER STEERING RETURN HOSE FAILS, A SUDDEN RUPTURE OF THE HOSE CAN OCCUR.
Consequeces:: THIS CAN RESULT IN A RAPID DRAINAGE OF THE POWER STEERING FLUID IN THE SYSTEM AND A COMPLETE LOSS OF POWER ASSISTANCE, INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL INSPECT AND REPLACE THE STEERING RETURN LINE HOSE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 13, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Notes:: VOLVO RECALL NO. 201.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2009 VOLVO C30 Complaints
The contact owns a 2009 Volvo C30. The contact stated while attempting to park the vehicle, the gear shifter shifted out of gear independently. No dealer or independent mechanic was contacted. The vehicle was not taken to a dealer or independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 106,000.;
2009 VOLVO C70 Complaints
Door actuator fault while driving, door opens slightly ajar while driving. Frequently happens while driving on highway with top up or down. Requires driver to hold door from swinging open around turns until there is a stop that allows driver to open and shut door again.;
2009 VOLVO S40 Complaints
I purchased the 2009 Volvo on 10/5 at M&M Auto Sales LLC and on 10/9 at 6:20 am my vehicles check engine light turned on and a transmission service urgent light turned on. On 10/11 I went to AAMCO and they informed me that the transmission needed repairs costing up to 4k. When I purchased the car the dealership disclosed to me that the vehicle is in perfect condition. As of 10/21 I went to a Mechanic Shop called Pegoraro and ran a full auto diagnostic on the vehicle. With repairs on the vehicle costing $12,433.03 which involve fixes to the Timing Belt, Cooling System Fluid Exchange, Drive Belt Tensioner/Idle Assembly, Automatic Transmission Assembly, Remove and Install, Brake Fluid Exchange, and Lastly Disc Brake Pads, Rotors and Calipers (Rear). Obviously the vehicle isn't in "perfect condition". After getting this diagnostic I was informed that the vehicles Odometer has been tampered with as well as a bunch of other codes have been turned off before I purchased this vehicle. I just want a refund for this vehicle and to take my business elsewhere.;
2009 VOLVO V50 Complaints
I HAD THE BRAKE PADS REPLACED, THEN THE PUMP ONLY TO NOT BE ABLE TO STOP THE CAR BECAUSE OF THE BOOSTER PUMP! I WENT RIGHT THROUGH A STOP SIGN. THE MECHANIC SAID HE SEES THIS PROBLEM ALL OF THE TIME WITH THESE CARS.;