MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT

Sep 09, 2008 — Recall Campaign #08V454000

MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT, ECLIPSE COUPE, AND MY 2007 ECLIPSE SPYDER VEHICLES. THE BRACKET THAT IS THE ATTACHMENT POINT FOR THE LEFT REAR FUEL TANK MOUNTING STRAP MAY HAVE BEEN IMPROPERLY FORMED DURING A METAL STAMPING PROCESS. THE PROCESS MAY HAVE CAUSED THE METAL TO HAVE A SPLIT IN THE AREA WHERE THE BOLT THAT HOLDS ONE OF THE TWO FUEL TANK STRAPS TO THE UNDERSIDE OF THE VEHICLE IS LOCATED. IN THE EVENT THE FUEL TANK IS FULL AND THE VEHICLE IS SUBJECT TO A SEVERE COLLISION, THE BRACKET MAY BREAK AND ALLOW THE FUEL TANK TO DROP DOWN, POSSIBLY CAUSING A FUEL LEAK.

The recall was influenced by the manufacturer with about 45,988 units affected.

See recall notice

NHTSA Safety Recall Notice

08V454000

Manufacturer:	Mitsubishi Motors North America, Inc.
Recall date:	September 09, 2008
NHTSA Campaign #:	08V454000
Units affected:	45,988

Description:: MITSUBISHI IS RECALLING 45,988 MY 2005-2007 ENDEAVOR, GALANT, ECLIPSE COUPE, AND MY 2007 ECLIPSE SPYDER VEHICLES. THE BRACKET THAT IS THE ATTACHMENT POINT FOR THE LEFT REAR FUEL TANK MOUNTING STRAP MAY HAVE BEEN IMPROPERLY FORMED DURING A METAL STAMPING PROCESS. THE PROCESS MAY HAVE CAUSED THE METAL TO HAVE A SPLIT IN THE AREA WHERE THE BOLT THAT HOLDS ONE OF THE TWO FUEL TANK STRAPS TO THE UNDERSIDE OF THE VEHICLE IS LOCATED. IN THE EVENT THE FUEL TANK IS FULL AND THE VEHICLE IS SUBJECT TO A SEVERE COLLISION, THE BRACKET MAY BREAK AND ALLOW THE FUEL TANK TO DROP DOWN, POSSIBLY CAUSING A FUEL LEAK.
Consequeces:: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Corrective action:: DEALERS WILL INSPECT TO SEE IF THE LEFT REAR FUEL TANK STRAP MOUNTING BRACKET HAS SPLITTING BEYOND A SPECIFIC LIMIT. VEHICLES WITH MODERATE TO SEVERE SPLITTING WILL BE REPAIRED USING A REINFORCEMENT CAP, A SPECIAL STRUCTURAL ADHESIVE, AND A RIVET TO REINFORCE THE FUEL TANK MOUNTING BRACKET. THE RECALL BEGAN ON SEPTEMBER 20, 2008. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.
Notes:: MITSUBISHI RECALL NO. SR-08-005.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.

Affects the following:

2007 MITSUBISHI ECLIPSE Complaints
With my vehicle the brakes go straight to the floor. I took it to the mitsubishi dealership closest to me (Bobmills mitsubishi Jacksonville Nc). When I got there i told them what was going on, and if you bleed the brakes they worked fine for 3 or 4 days but after that the brakes would just go to the floor again. They said they bleed the brakes to replace the fluid and then tested the ABS module for a recall and said it was fine but I had a collapsed brake line in the rear. I replaced all the brake lines on the vehicle and did a complete bleed again to remove any air. The brakes now go all the way to the floor again. I was trying to bleed them just to see if I could get some pressure, but 3 of the lines aren't getting pressure. I decided to check and bleed at the master cylinder, I had plenty of pressure coming out so I know that's good. Then I checked the bleed pressure at the ABS module thats on the recall and I am only getting pressure from the drivers front tire, the other 3 are not giving pressure at all, even if you pump the brakes while they are open. So I know the cylinders in that ABS module are bad. So I called the dealership again and they are refusing to do it because they said they don't work on vehicles that old.;
2007 MITSUBISHI ECLIPSE SPYDER Complaints
TL* THE CONTACT OWNS A 2007 MITSUBISHI ECLIPSE SPYDER. WHILE THE CONTACT'S DAUGHTER WAS DRIVING 30 MPH, THE DRIVER DEPRESSED THE BRAKE PEDAL, BUT THE BRAKES FAILED. AS A RESULT, THE DRIVER STRUCK THE REAR OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE HEAD, NECK, AND SPINE AND LOST CONSCIOUSNESS. MEDICAL ATTENTION WAS REQUIRED AND THE DRIVER WAS TAKEN TO THE HOSPITAL. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A COLLISION CENTER. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT WAS UNSURE IF THE VEHICLE COULD BE REPAIRED OR WAS DESTROYED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND MADE VARIOUS ATTEMPTS TO CONTACT THE DRIVER. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V337000 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 112,000.;
2007 MITSUBISHI ENDEAVOR Complaints
WATER UNDER DRIVERS SIDE CARPET ONLY. FOUND AC / HEATER BOX HOUSING DRAIN FITMENT AGAINST BODY BULKHEAD LEAKING. AC DRAIN IS ON DRIVERS SIDE ABOVE ACCEL. PEDAL AREA.;
2007 MITSUBISHI GALANT Complaints
TL* THE CONTACT OWNS A 2007 MITSUBISHI GALANT. THE CONTACT STATED THAT THE TRANSMISSION SLIPPED AND WOULD NOT SHIFT INTO ANY OTHER GEAR. WHEN THE VEHICLE WAS TURNED OFF AND RESTARTED, IT OPERATED NORMALLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. A NEW TRANSMISSION WAS ORDERED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.;