CHRYSLER IS RECALLING 6,138 MY 2009 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES

Feb 05, 2009 — Recall Campaign #09V046000

CHRYSLER IS RECALLING 6,138 MY 2009 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. UNUSED ELECTRICAL CONNECTORS FOR THE BLIND SPOT DETECTION SYSTEM MAY BECOME CORRODED AND COULD SHORT CIRCUIT, WHICH CAN CAUSE A VARIETY OF CONDITIONS.

The recall was influenced by the manufacturer with about 6,138 units affected.

See recall notice

NHTSA Safety Recall Notice

09V046000

Manufacturer:	Chrysler (FCA US, LLC)
Recall date:	February 05, 2009
NHTSA Campaign #:	09V046000
Units affected:	6,138

Description:: CHRYSLER IS RECALLING 6,138 MY 2009 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. UNUSED ELECTRICAL CONNECTORS FOR THE BLIND SPOT DETECTION SYSTEM MAY BECOME CORRODED AND COULD SHORT CIRCUIT, WHICH CAN CAUSE A VARIETY OF CONDITIONS.
Consequeces:: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTORS COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Corrective action:: DEALERS WILL SEAL THE POWER CIRCUIT AT THE SUBJECT CONNECTOR AND REPLACE THE FUSE FOR THIS CIRCUIT IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 9, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Notes:: CHRYSLER RECALL NO. J01.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2009 CHRYSLER TOWN AND COUNTRY Complaints
The contact owns a 2009 Chrysler Town and Country. The contact stated that while the vehicle was parked and unoccupied, the contact became aware that the steering wheel air bag and the front passenger's side air bags had deployed unexpectedly. The contact stated that the windshield was fractured from the air bags deployment. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 240,000.;
2009 DODGE GRAND CARAVAN Complaints
In August 2024, the airbag system in a 2009 Dodge Grand Caravan (VIN: [XXX] ) deployed unexpectedly while the vehicle was parked and not in operation. There was no collision, impact, or known external trigger at the time of deployment. The malfunction involved the airbag restraint system and/or related electrical or control components. An unexpected airbag deployment creates a serious safety concern because it could injure vehicle occupants or bystanders and indicates a potential defect in the restraint system. The vehicle was immediately taken to Banister Chrysler Dodge Jeep Ram in Hampton, Virginia, where it has remained since the incident. To the best of our knowledge, the vehicle has remained in dealership/manufacturer custody and should be available for inspection. The manufacturer indicated they were reviewing the matter and determining the value of the vehicle; however, despite extended time passing, no repair, replacement, or written resolution has been provided. The issue has not been reproduced because the vehicle has remained out of service since the incident. It is UNKNOWN whether the precise cause has been formally confirmed by the manufacturer or dealership. No injuries occurred, but the incident placed the safety of the owners and others at risk because a critical safety restraint system deployed without warning while the vehicle was stationary. Documented NHTSA recalls affecting Dodge Grand Caravan airbag systems and related models demonstrate prior manufacturer awareness of airbag-related safety defects. Although this VIN currently shows no open recall, the spontaneous deployment raises concern regarding unresolved or inadequately corrected airbag system defects. No known warning lamps or dashboard messages were specifically recalled prior to the incident. Any additional warning indicators are UNKNOWN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);