VOLVO IS RECALLING 17,614 MY 2008-2009 S80, V70, AND XC70 VEHICLES

Jun 12, 2009 — Recall Campaign #09V218000

VOLVO IS RECALLING 17,614 MY 2008-2009 S80, V70, AND XC70 VEHICLES. THE ENGINE COOLING FAN MAY STOP WORKING DUE TO A SOFTWARE PROGRAMMING ERROR IN THE FAN CONTROL MODULE (FCM). DEPENDING ON DRIVING CONDITIONS, THE CUSTOMER MAY EXPERIENCE REDUCED AIR CONDITIONING PERFORMANCE, AND/OR RAPID INCREASE IN ENGINE COOLANT TEMPERATURE.

The recall was influenced by the manufacturer with about 17,614 units affected.

See recall notice

NHTSA Safety Recall Notice

09V218000

Manufacturer:	Volvo Car USA, LLC
Recall date:	June 12, 2009
NHTSA Campaign #:	09V218000
Units affected:	17,614

Description:: VOLVO IS RECALLING 17,614 MY 2008-2009 S80, V70, AND XC70 VEHICLES. THE ENGINE COOLING FAN MAY STOP WORKING DUE TO A SOFTWARE PROGRAMMING ERROR IN THE FAN CONTROL MODULE (FCM). DEPENDING ON DRIVING CONDITIONS, THE CUSTOMER MAY EXPERIENCE REDUCED AIR CONDITIONING PERFORMANCE, AND/OR RAPID INCREASE IN ENGINE COOLANT TEMPERATURE.
Consequeces:: THIS SITUATION MAY RESULT IN LOSS OF COOLING SYSTEM FUNCTION AND ENGINE FAILURE. THE DRIVER MAY NOT HAVE SUFFICIENT TIME TO REACT TO THE WARNING LIGHT(S) OR THE TEXT MESSAGE IN THE INSTRUMENT PANEL, INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL REPLACE THE FAN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.
Notes:: VOLVO RECALL NO. R214.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2009 VOLVO S80 Complaints
The headlight system malfunctioned. It is available for inspection upon request. The low beam failure error occurred, which led to an inspection of the headlight system. The wiring inside the headlight assembly failed. The insulation on bulb wires is crumbling everywhere and causing short circuits from exposed wire conductors. This causes a safety issue because the bulbs stop functioning, impairing visibility of the car, visibility of the road, and disabling motion intent lights like the turn signals. Bare wires touching can also lead to overheating and fires or failures of the headlight electrical system. Humidity may damage the exposed wires and cause bulb failure or wire overheating. The wiring harnesses may also overheat. The wire insulation problem was confirmed by an independent service center on multiple cars of this model.;
2009 VOLVO V70 Complaints
SRS WARNING LIGHT ILLUMINATED AT APPROXIMATELY 70,000 MILES, 4.5 YEARS AFTER PURCHASING VOLVO DIRECTLY FROM THE FACTORY IN SWEDEN. THE LIGHT REMAINED ON FOR A FEW DAYS, THEN TURNED OFF. THIS OCCURRED REGULARLY FOR 4 MONTHS UNTIL THE LIGHT REMAINED ON INDEFINITELY. WHEN I FINALLY TOOK THE VEHICLE IN FOR SERVICING, THE ERROR CODE INDICATED A FAULTY OCCUPANT WEIGHT SENSOR (OWS) EMBEDDED IN THE PASSENGER SEAT. THE PASSENGER AIR BAG WILL NO LONGER DEPLOY IN THE EVENT OF AN ACCIDENT BECAUSE THE SENSOR WILL NO LONGER IDENTIFY A PASSENGER IN THE CAR. IT IS UNCLEAR WHETHER THIS ALSO DISABLES THE DRIVER (PRIMARY) AIR BAG, AS WELL AS THE SIDE AIR BAGS. I CONTACTED VOLVO USA SHORTLY AFTER THE 5 YEAR MANUFACTURER WARRANTY EXPIRED AND THEY EMPHATICALLY CLAIMED THAT THIS EGREGIOUS SAFETY ISSUE WAS NO LONGER THEIR CONCERN. RESPECTFULLY, PLEASE NOTE THAT DUE TO THIS FAULTY OWS THE CAR IS EXTREMELY DANGEROUS TO OPERATE AND THAT VOLVO SHOULD BE RESPONSIBLE FOR FIXING THIS ERROR. *JS;
2009 VOLVO XC70 Complaints
When it rains, water continuously drips through the windshield. It is distracting and obstructs my vision.;