ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150

Jun 17, 2010 — Recall Campaign #10V270000

ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.

The recall was influenced by the Office of Defects Investigation with about 4 units affected.

See recall notice

NHTSA Safety Recall Notice

10V270000

Manufacturer:	Toyota Motor Corporation
Recall date:	June 17, 2010
NHTSA Campaign #:	10V270000
Units affected:	4

Description:: ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SWIVEL PLATE. THE WELD COULD FAIL.
Consequeces:: THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
Corrective action:: THE SWIVEL PLATE WILL BE REPLACED FREE OF CHARGE IF NECESSARY. THE RECALL BEGAN ON JUNE 8, 2010. OWNERS MAY CONTACT ACCESS OPTION AT 831-722-6804.
Notes:: THIS RECALL ONLY PERTAINS TO VEHICLES ALTERED BY ACCESS OPTIONS AND HAS NO RELATION TO ANY VEHICLES MANUFACTURED BY FORD, TOYOTA, AND DODGE.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2000 DODGE GRAND CARAVAN Complaints
The contact owns a 2000 Dodge Grand Caravan. The contact stated that while driving at 55 MPH, there was an abnormal noise and noticed that the vehicle's windshield wiper and blinkers had become inoperable. No warning light was illuminated. The vehicle had been diagnosed by an independent mechanic. The contact was informed that the failure was due to a faulty wiper transmission linkage, a relay, and a switch. The relay and switch were replaced however, the wiper transmission linkage was not repaired due to parts not being available. The manufacturer was made aware of the failure and determined that parts were not available. The failure mileage was approximately 110.000;
2000 FORD E-150 Complaints
The contact owns a 2000 Ford E-150. The contact stated that while driving at approximately 20 MPH, the driver's side air bag exploded hitting her face and chest. The contact stated that she also observed smoke emanating from behind the air bag and when the vehicle stopped, she disconnected and reconnected the battery. The vehicle was restarted, and she continued to drive. Medical attention was not needed. A police report was not taken. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 116,600.;
2006 TOYOTA SIENNA Complaints
The contact owns a 2006 Toyota Sienna. The contact stated that while the vehicle was at the dealer for a recall repair, the mechanic discovered large holes in the center of the subframe caused by rust. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 218,000.;
2007 FORD E-350 Complaints
AS I AM DRIVING SPESIFICLY ON EXPRESS WAY ALL GAGES SHUT DOWN FOR FEW SECONDS AND IN SOME CASES UP TO 2 TO 5 MINUTES, THE LONGER TIME DOES NOT OCURE VERY OFTEN, THIS HAPPENS 2 TO 4 TIMES IN A 1.I/2 HOURS OF DRIVING, SOME TIMES LESS LIKE ONE TIME ONLY. ALSO WHEN THIS HAPPEN THE POWER ON THE WINDOWS DIES AND SO THE RADIO.;