CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 LEFT HAND DRIVE JEEP LIBERTY

Jul 07, 2010 — Recall Campaign #10V315000

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 LEFT HAND DRIVE JEEP LIBERTY, DODGE NITRO AND RAM 1500 TRUCK; RIGHT AND LEFT HAND DRIVE JEEP WRANGLER VEHICLES. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY FORMED MASTER CYLINDER TO HYDRAULIC CONTROL UNIT (HCU) BRAKE TUBE ASSEMBLY END FLARE.

The recall was influenced by the manufacturer with about 20,626 units affected.

See recall notice

NHTSA Safety Recall Notice

10V315000

Manufacturer:	Chrysler (FCA US, LLC)
Recall date:	July 07, 2010
NHTSA Campaign #:	10V315000
Units affected:	20,626

Description:: CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 LEFT HAND DRIVE JEEP LIBERTY, DODGE NITRO AND RAM 1500 TRUCK; RIGHT AND LEFT HAND DRIVE JEEP WRANGLER VEHICLES. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY FORMED MASTER CYLINDER TO HYDRAULIC CONTROL UNIT (HCU) BRAKE TUBE ASSEMBLY END FLARE.
Consequeces:: THIS COULD LEAD TO LOSS OF BRAKE FLUID AND REDUCED BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL REPLACE THE BRAKE TUBES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
Notes:: CHRYSLER SAFETY RECALL NO. K15.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2010 DODGE NITRO Complaints
The contact owns a 2010 Dodge Nitro. The contact stated that while attempting to start the vehicle, the engine cranked, but the vehicle failed to start, and it became inoperable. There was no warning light illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact believed that the failure might be related to the Totally Integrated Power Module (TIPM). The manufacturer was not made aware of the failure. The approximate failure mileage was 163,000.;
2010 DODGE RAM 1500 Complaints
The contact owns a 2010 Dodge Ram 1500. The contact stated while driving at an undisclosed speed, the driveshaft detached. No warning lights were illuminated. The contact received notification for NHTSA Campaign Number: 13V038000 (Power Train) however, the part to complete the recall repair was not yet available. The vehicle was towed to a dealer, where it was diagnosed that the rear axle pinion nut needed to be replaced. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 262,420. ;
2010 JEEP LIBERTY Complaints
Drivers side headrest (AHR) deployed unexpectedly with no impact of any kind. Upon inspection the AHR mechanism could not be reset due to a broken piece of plastic for a rod. Will not lock back into position.;
2010 JEEP WRANGLER Complaints
My vehicle has experienced a complete failure of the ABS Control Module. A dealer diagnosis confirmed internal module failure. The symptoms are: - All ABS system warning lights illuminated (ABS, traction control, brake, sway bar) - Odometer and speedometer stop working while driving - All brake lights remain on continuously - Vehicle exhibits erratic shifting / rough braking This is a documented safety defect affecting many Chrysler/Dodge/Jeep owners where the dealer confirms the ABS module is defective but cannot repair due to the part being on national backorder with no ETA. I am being told the part is backordered indefinitely. I am left driving an unsafe vehicle with no functioning ABS, stability control, or accurate speed/odometer reading, or parking a vehicle I am still paying for and insuring. I am formally requesting: 1. Immediate provision of a replacement ABS module, or a loaner/rental vehicle at FCA's expense until repair;