VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM

Nov 08, 2010 — Recall Campaign #10V566000

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

The recall was influenced by the manufacturer with about 416 units affected.

See recall notice

NHTSA Safety Recall Notice

10V566000

Manufacturer:	Volvo Car USA, LLC
Recall date:	November 08, 2010
NHTSA Campaign #:	10V566000
Units affected:	416

Description:: VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequeces:: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Corrective action:: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
Notes:: VOLVO SAFETY RECALL NO. R231.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2009 VOLVO S60 Complaints
The contact owns a 2009 Volvo S60. The contact stated that while driving at an undisclosed speed, the column turn signal lever detached. The contact stated that the turn signal and headlight switches were inoperable due to the failure. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure, and an appointment was scheduled for a future date. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,000.;
2010 VOLVO C30 Complaints
While on the freeway my sunroof shattered and spilled a bunch of glass fragments all over me, I believe a rock or some kind of other object, never found out what hit it or if it was hit, from the freeway hit it, so I don't know if it counts as a vehicle safety problem but I wanted to make a report just in case it counts as one. My safety was put at risk by having glass falling on top off me while going around 60mph on the freeway, the sudden noise of the glass breaking followed by the glass falling on me caused me to swerve and it left me shaken and covered in glass. I ended up pulling over on the shoulder to relax myself and get all the glass off of me and my seat, no one was hurt or injured. There was no problem confirmed other than the sunroof being broken. The component was not inspected. There were no other warnings or symptoms of the problem prior to it breaking.;
2010 VOLVO C70 Complaints
I HAVE HAD THE PASSENGER DOOR OPEN ON ITS OWN WHILE LOCKED AND DRIVING ON THE EXPRESSWAY AT LEAST 2 TIMES WITH NO ONE IN THE SEAT. THE DOME LIGHT GOES ON AND THE WARNING LIGHT ON THE DASH LIGHTS UP THAT DOOR IS AJAR. THE PASSENGER DOOR HAS ALSO OPENED ON ITS OWN WHEN ITS BEEN PARKED (OFF) IN MY GARAGE AT LEAST 2 TIMES AS WELL. DOME LIGHT ON FOR WHAT COULD BE HOURS (OVERNIGHT)! UNSAFE AND A POTENTIAL BATTERY DRAINER.*DT *TR;
2010 VOLVO S40 Complaints
Hello. The warning of the device is on the dashboard that the SRS is not functional;
2010 VOLVO S80 Complaints
On [XXX] I was driving from Opelika, AL to Birmingham, AL. About 20 miles from home while driving on [XXX] in the left lane, my car would not accelerate. I pushe9 it down to the floor and there was no gas, so I had to get over to the right lane while rolling to get out of danger of the traffic and large trucks. MY car has been towed three time in about 3 month in 2025. I had it towed from my work parking lot twice because it would not crank. We bought new batteries, changed out the key batteries and this last incident. We had just got the car out of the shop for a fuel pump & fuel pump control module. (see receipt). I learned there was a Safety Recall from the NHTSA. However, when I called only to learn that my car had not been recalled. Therefore, I am quite confused because the safety issue recall no 09V343000 for 2010,S80 appears to be having the same issue. the software within the Central Electronic module (CEM) is not sending the signal to the fuel pump that was just replaced to the electronic module (PEM). The missing signal to the PEM inhibits the start of the fuel pump. This was a very frightening experience having a car stop on the highway while in the fast lane. Now the fear of it happening again is quite frightening, that's why I confused as to the seriousness of this electrical system software issue is not being taken for granted on my vehicle. If it was a problem for some, why would it not be a problem for all. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);