VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES

Nov 17, 2010 — Recall Campaign #10V579000

VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES. THE SOFTWARE CALIBRATION FOR THE FUEL CUT-OFF FUNCTIONALITY IN THE ENGINE CONTROL MODULE (ECM) IS TOO SENSITIVE.

The recall was influenced by the manufacturer with about 6,046 units affected.

See recall notice

NHTSA Safety Recall Notice

10V579000

Manufacturer:	Volvo Car USA, LLC
Recall date:	November 17, 2010
NHTSA Campaign #:	10V579000
Units affected:	6,046

Description:: VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES. THE SOFTWARE CALIBRATION FOR THE FUEL CUT-OFF FUNCTIONALITY IN THE ENGINE CONTROL MODULE (ECM) IS TOO SENSITIVE.
Consequeces:: SUDDEN ENGINE STALL COULD OCCUR INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL UPDATE THE ECM AND TCM WITH NEW SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 10, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT [email protected].
Notes:: VOLVO SAFETY RECALL NO. R234.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2011 VOLVO S60 Complaints
New tires (all 4) installed on November 4, 2023 at Walmart in Myrtle Beach, SC. Drove car to New Jersey on Nov. 5, arrived November 6. Tire pressure low indicator came on november 14. Drove to Old Bridge, NJ Walmart Auto Center to have them look at them. Arrived around 6 pm. Went isnide to request that car be put on lift to look at them, and fill with air. Female employee declined to put car up on lift, but had tech put aior in them. Told me to come back the next day to put up on lift. Light went off. Drove out to eat something at a Five Guys near the Walmart. Drove back to hotel in South Brunswick. Next day started driving back up to Old Bridge Walmart, was in traffic, braked and slid into car in front of me. Very little traction.;
2011 VOLVO S80 Complaints
TL* THE CONTACT OWNS A 2011 VOLVO S80. THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS, THE STABILIZATION WARNING LIGHT ILLUMINATED AND STARTED FLASHING. THE STEERING WHEEL FAILED TO MOVE AND VEHICLE LOSS POWER. THE CHARGING WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE ALTERNATOR AND BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE CONTACT CALLED PEDERSEN VOLVO CARS (4455 S MASON ST, FORT COLLINS, CO 80525, (970)223-8500) HOWEVER, THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 25,000. THE CONSUMER STATED SHORTLY AFTER PURCHASING THE VEHICLE THE "CHARGING SYSTEM FAILURE" WARNING LIGHT WOULD INTERMITTENTLY ILLUMINATE WHILE DRIVING. THE VEHICLE HAD AN INCIDENT IN WHICH IT WOULD NOT POWER ON. THE BATTERY WAS REPLACED. THE CHARGING FAILURE LIGHT CONTINUED FLASH. THE ALTERNATOR WAS REPLACED, BUT THE FAILURE PERSISTED. THE CONSUMER THEN EXPERIENCED A TOTAL SYSTEM FAILURE WILE DRIVING. IT WAS DETERMINED THE BATTERY WAS DEFECTIVE. THE BATTERY WAS REPLACED, BUT THE WARNING LIGHTS RETURNED. IT WAS DETERMINE VIA SERVICE BULLETIN FROM 2015 THE BATTERY AND ALTERNATOR LOST COMMUNICATION. THE FAILURE WAS DUE TO THE ANTI TAMPER UNIT. THE MANUFACTURER WAS CONTACTED, BUT DID NOT OFFER ANY ASSISTANCE. HOWEVER, THE DEALER OFFERED A 15% DISCOUNT.;
2011 VOLVO XC60 Complaints
Windshield is original from Volvo but leaks during rain and car washes. Rain floods my driver’s side floor board and heavy enough might effect my electrical system.;
2011 VOLVO XC70 Complaints
The steering would randomly lock (or at least become very stiff). This occurred when the vehicle was warm and seemed to be mostly low speed sharper turns. Turning the wheel in the opposite direction freed it up. I replaced the steering rack to solve the problem.;